LEMON Manuals: Even more car manuals for everyone
Home >> Toyota >> 2001 >> Sienna CE >> Repair and Diagnosis >> External Pages >> Different car >> Section 359 (Air Conditioning System) >> Compressor And Magnetic Clutch >> Removal

Compressor And Magnetic Clutch: Removal

WARNING: This page is about a different car, the 2002 Toyota Prius. However, it is still accessible from the selected car via links, so may be relevant.
  1. Run engine at idle speed with A/C on for approximately 10 minutes  .
  2. Stop engine  .
  3. Disconnect negative (-) terminal cable from battery  .
  4. Discharge refrigerant from refrigeration system  .
  5. Remove drive belt  . See REMOVE DRIVE BELT .
  6. Remove engine under cover RH  . See Figure.
    7. CAUTION: Cap the open fittings immediately to keep moisture or dirt out of the system.
    Fig 1: Locating A/C Compressor To Suction & Discharge Tube Connection Bolts
    G01065435Courtesy of © TOYOTA, LICENSE AGREEMENT TMS1002
  7. Remove the 2 bolts and disconnect discharge and suction hoses  .
  8. Remove compressor:
    1. Disconnect the connector.
    2. Remove the 4 bolts and compressor.
      Fig 2: Locating A/C Compressor Mounting Bolts
      G01065436Courtesy of © TOYOTA, LICENSE AGREEMENT TMS1002
scientia non olet · About LEMON Manuals