LEMON Manuals: Even more car manuals for everyone
Home >> Tesla >> 2022 >> Model X Base >> Repair and Diagnosis (Single Page) >> Accessories & Equipment >> Interior/Exterior Trim >> Interior Trim (Model X) (2 Of 2) >> Carpeting And Mats >> Carpet - Podium - Remove And Replace >> Install

Carpet - Podium - Remove And Replace: Install

  1. Install 1st row podium seat riser carpet.
    NOTE: 1x push clip.
    G15397546Courtesy of TESLA, INC.
  2. Install 1st row podium RH inner seat riser trim covers.
    NOTE: 2x clips, Install inner inboard cover first then inner outboard cover, Be sure to route seat harness through inner outboard cover.
    G15397547Courtesy of TESLA, INC.
    G15397548Courtesy of TESLA, INC.
    G15397549Courtesy of TESLA, INC.
  3. Install 1st row podium LH inner seat riser trim covers.
    NOTE: 2x clips, Install inner inboard cover first then inner outboard cover, Be sure to route seat harness through inner outboard cover.
    G15397550Courtesy of TESLA, INC.
    G15397551Courtesy of TESLA, INC.
    G15397552Courtesy of TESLA, INC.
  4. Install the center console assembly. See CENTER CONSOLE ASSEMBLY - 1ST ROW (REMOVE AND INSTALL) .
  5. Install LH front seat into vehicle.
    NOTE: Recommend Assistance, Take care not to damage surrounding components while lifting the seat into the vehicle.
    G15397553Courtesy of TESLA, INC.
  6. Position chair to gain access below seat bottom and connect LH side body harness to seat controller.
    NOTE: 2x connectors, 1x clip, Engage red locking tab on black connector, Recommend assistance.
    G15397554Courtesy of TESLA, INC.
  7. Position LH front seat upright for bolt installation.
    NOTE: Recommend assistance.
    G15397555Courtesy of TESLA, INC.
  8. Install RH front seat into vehicle.
    NOTE: Recommend Assistance, Take care not to damage surrounding components while lifting the seat into the vehicle.
    G15397556Courtesy of TESLA, INC.
  9. Position chair to gain access below seat bottom and connect RH side body harness to seat controller.
    NOTE: 2x connectors, 1x clip, Engage red locking tab on black connector, Recommend assistance.
    G15397557Courtesy of TESLA, INC.
  10. Position RH front seat upright for bolt installation.
    NOTE: Recommend assistance.
    G15397558Courtesy of TESLA, INC.
  11. Connect First Responder Loop and LV battery connector.
    NOTE: 2x connectors, Secure FRL first, Seat LV battery connection and push black connector lock inwards to secure, Engage upper locking tab when fully seated.
    G15397559Courtesy of TESLA, INC.
    G15397560Courtesy of TESLA, INC.
  12. Install rear underhood apron.
    NOTE: 11x clips, 2x datums.
    G15397561Courtesy of TESLA, INC.
    G15397562Courtesy of TESLA, INC.
  13. Close hood.
  14. Move RH front seat forward.
    G15397563Courtesy of TESLA, INC.
  15. Secure RH front seat belt.
    G15397564Courtesy of TESLA, INC.
    G15397565Courtesy of TESLA, INC.
  16. Install bolts securing RH front seat rear tracks to vehicle.
    NOTE: 2x patch bolts, T45P, 34 N.m, Install new bolts.
    G15397566Courtesy of TESLA, INC.
  17. Move RH front seat backward.
    G15397567Courtesy of TESLA, INC.
  18. Install bolts securing both RH front seat front tracks to vehicle.
    NOTE: 2x patch bolts, T45P, 34 N.m, Install new bolts.
    G15397568Courtesy of TESLA, INC.
  19. Move RH front seat to original position.
    G15397569Courtesy of TESLA, INC.
  20. Close RH front door.
    G15397570Courtesy of TESLA, INC.
  21. Move LH front seat forward.
    G15397571Courtesy of TESLA, INC.
  22. Secure LH front seat belt.
    NOTE: Engage buckle onto lap pretensioner and perform push pull test to confirm buckle is locked onto pretensioner.
    G15397572Courtesy of TESLA, INC.
    G15397573Courtesy of TESLA, INC.
  23. Install bolts securing LH front seat rear tracks to vehicle.
    NOTE: 2x patch bolts, T45P, 34 N.m, Install new bolts.
    G15397574Courtesy of TESLA, INC.
  24. Move LH front seat backward.
    G15397575Courtesy of TESLA, INC.
  25. Install bolts securing both LH front seat front tracks to vehicle.
    NOTE: 2x patch bolts, T45P, 34 N.m, Install new bolts.
    G15397576Courtesy of TESLA, INC.
  26. Move LH front seat to original position.
    G15397577Courtesy of TESLA, INC.
  27. Calibrate the rear doors.
    NOTE: If the "Calibration Needed" message appears on the vehicle touchscreen, touch and hold Calibrate  to calibrate the rear doors.
scientia non olet · About LEMON Manuals