LEMON Manuals: Even more car manuals for everyone
Home >> Tesla >> 2018 >> Model 3 Performance >> Repair and Diagnosis (Single Page) >> Accessories & Equipment >> Infotainment >> Electrical System (2 Of 2) -- Model 3 >> Exterior Lights >> Headlight - Pair - Remove and Replace >> Remove

Headlight - Pair - Remove and Replace: Remove

  1. Enable Service Mode. See Service Mode .
  2. Remove the rear underhood apron. See UNDERHOOD APRON - REAR (REMOVE AND REPLACE) .
  3. Remove the cabin intake duct. See DUCT - CABIN INTAKE (REMOVE AND REPLACE) .
  4. Remove the hood latch cover. See COVER - HOOD LATCH (REMOVE AND REPLACE) .
  5. Remove the underhood storage unit. See UNDERHOOD STORAGE UNIT (REMOVE AND REPLACE) .
  6. Remove the front fascia. See FASCIA - FRONT (REMOVE AND INSTALL) .
  7. Disconnect the electrical connector from the LH headlight.
    NOTE: If the connector has a red locking tab:  DO NOT push down on the red locking tab. Pull the tab away from the connector until the connector is unlocked, and then continue pulling to release the connector.
    G14744262Courtesy of TESLA, INC.
  8. Remove the bolt that attaches the fender bracket to the body, and then remove the bracket from the vehicle.

    Tip: Use of the following tool(s) is recommended:

    • Torx T20 socket
    • in std ratchet
    • in torque wrench (installation only)
    • 4 in extension

    G00656939Courtesy of TESLA, INC.
  9. Remove the fastener(s) that attach the LH headlight to the body.
    NOTE: The headlight might not be equipped with a lower fastener.

    Tip: Use of the following tool(s) is recommended:

    • 10 mm socket
    • 1/4 in std ratchet
    • 1/4 in torque wrench (installation only)
    • 2 in extension
    G14744264Courtesy of TESLA, INC.
    G14744265Courtesy of TESLA, INC.
  10. Remove the headlight from the vehicle.
  11. Repeat steps 7  through 10  for the RH side headlight.
scientia non olet · About LEMON Manuals