LEMON Manuals: Even more car manuals for everyone
Home >> Suzuki >> 2012 >> Equator Base >> Repair and Diagnosis >> Maintenance >> Procedures >> Maintenance & Lubrication >> Scheduled Maintenance >> Periodic Maintenance [for USA and Canada] >> For United States and Canada: Schedule 1 >> Chassis And Body Maintenance

Chassis And Body Maintenance

Abbreviations: R = Replace. I = Inspect. Correct or replace if necessary. L = Lubricate. [ ]: At the mileage intervals only.

CHASSIS AND BODY MAINTENANCE

MAINTENANCE OPERATION MAINTENANCE INTERVAL Reference Section - Page or - Content Title
Perform at number of miles, kilometers or months, whichever comes first. Miles x 1, 000 (km x 1, 000) Months 3.75 (6) 3 7.5 (12) 6 11.25 (18) 9 15 (24) 12 18.75 (30) 15 22.5 (36) 18 26.25 (42) 21 30 (48) 24
Brake lines and cables         I       I CHECKING BRAKE LINE AND CABLES 
Brake pads and rotors     I   I   I   I CHECKING DISC BRAKE 
Automatic transmission fluid and manual transmission fluid NOTE (1)       I       I CHECKING THE A/T FLUID (ATF) 
M/T OIL CHECKING [FS6R31A] 
M/T OIL CHECKING [FS5R30A] 
Transfer fluid and front final drive oil NOTE (1)       I       I TRANSFER FLUID: REPLACEMENT , CHECKING DIFFERENTIAL GEAR OIL [R180A] 
Rear final drive oil NOTE (1)       I       I CHECKING DIFFERENTIAL GEAR OIL [C200] 
CHECKING DIFFERENTIAL GEAR OIL [M226] 
CHECKING DIFFERENTIAL GEAR OIL [M226 (ELD)] 
Steering gear, linkage, axle, and suspension parts     I   I   I   I CHECKING STEERING GEAR AND LINKAGE , CHECKING AXLE AND SUSPENSION PARTS 
Tire rotation NOTE (2)                 TIRE ROTATION 
Drive shaft boots and propeller shaft (4WD)     I   I   I   I CHECKING AXLE AND SUSPENSION PARTS 
Exhaust system     I   I   I   I CHECKING EXHAUST SYSTEM 
In-cabin microfilter         R       R IN-CABIN MICROFILTER REMOVAL AND INSTALLATION 
(1) If towing a trailer, or using a camper or a car-top carrier, or driving on rough or muddy roads, change (not just inspect) oil at every 30, 000 miles (48, 000 km) or 24 months. Using automatic transmission fluid other than SUZUKI approved Matic S ATF or Matic J ATF will cause deterioration in driveability and automatic transmission durability, and may damage the automatic transmission. 
(2) If towing a trailer, or using a camper or a car-top carrier, or driving on rough or muddy roads, change (not just inspect) oil at every 30, 000 miles (48, 000 km) or 24 months.
(3) Refer to "TIRE ROTATION " under the "General maintenance" heading earlier in this service information.
CHASSIS AND BODY MAINTENANCE INTERVAL

MAINTENANCE OPERATION MAINTENANCE INTERVAL Reference Section - Page or - Content Title
Perform at number of miles, kilometers or months, whichever comes first. Miles x 1, 000 (km x 1, 000) Months 33.75 (54) 27 37.5 (60) 30 41.25 (66) 33 45 (72) 36 48.75 (78) 39 52.5 (84) 42 56.25 (90) 45 60 (96) 48
Brake lines and cables         I       I CHECKING BRAKE LINE AND CABLES 
Brake pads and rotors     I   I   I   I CHECKING DISC BRAKE 
Automatic transmission fluid and Manual transmission fluid NOTE (1)       I       I CHECKING THE A/T FLUID (ATF) 
M/T OIL CHECKING [FS6R31A] 
M/T OIL CHECKING [FS5R30A] 
Transfer fluid and front final drive oil NOTE (1)       I       I TRANSFER FLUID: REPLACEMENT , CHECKING DIFFERENTIAL GEAR OIL [R180A] 
Rear final drive oil NOTE (1)       I       I CHECKING DIFFERENTIAL GEAR OIL [C200] 
CHECKING DIFFERENTIAL GEAR OIL [M226] 
CHECKING DIFFERENTIAL GEAR OIL [M226 (ELD)] 
Steering gear, linkage, axle, and suspension parts     I   I   I   I CHECKING STEERING GEAR AND LINKAGE , CHECKING AXLE AND SUSPENSION PARTS 
Tire Rotation NOTE (2)                 TIRE ROTATION 
Drive shaft boots and propeller shaft (4WD)     I   I   I   I CHECKING AXLE AND SUSPENSION PARTS 
Exhaust system     I   I   I   I CHECKING EXHAUST SYSTEM 
In-cabin microfilter         R       R IN-CABIN MICROFILTER REMOVAL AND INSTALLATION 
(1) If towing a trailer, or using a camper or a car-top carrier, or driving on rough or muddy roads, change (not just inspect) oil at every 30, 000 miles (48, 000 km) or 24 months. Using automatic transmission fluid other than SUZUKI approved Matic S ATF or Matic J ATF will cause deterioration in driveability and automatic transmission durability, and may damage the automatic transmission. 
(2) If towing a trailer, or using a camper or a car-top carrier, or driving on rough or muddy roads, change (not just inspect) oil at every 30, 000 miles (48, 000 km) or 24 months.
(3) Refer to "TIRE ROTATION " under the "General maintenance" heading earlier in this service information.
scientia non olet · About LEMON Manuals