LEMON Manuals: Even more car manuals for everyone
Home >> Suzuki >> 2001 >> XL-7 Limited >> Repair and Diagnosis >> External Pages >> Different car >> Section 144 (Differential & 4WD System) >> Rear >> Repair Instructions >> Rear Differential Gear Oil Inspection & Change

Rear Differential Gear Oil Inspection & Change

WARNING: This page is about a different car, the 2003 Suzuki Vitara, 2002 Suzuki Vitara, 2001 Suzuki Vitara, 2000 Suzuki Vitara, and 1999 Suzuki Vitara. However, it is still accessible from the selected car via links, so may be relevant.
NOTE:
  • Hypoid gear oil must be used for differential.
  • It is highly recommended to use SAE 80W-90 viscosity.
  1. Before oil change or inspection, be sure to stop engine and lift up vehicle horizontally.
  2. Check oil level and existence of leakage. If leakage is found, correct its cause.
  3. Drain old oil and pour proper amount of gear oil as specified (roughly up to level hole).
    Fig 1: Identifying Gear Oil Level
    G01356832Courtesy of SUZUKI OF AMERICA CORP.
  4. Torque drain and level/filler plugs to specification.

    "A":  Sealant 99000-31110

    Tightening torque 

    Differential oil level/filler plug (a):  50 N.m (5.0 kg-m, 36.5 lb-ft)

    Differential oil drain plug (b):  28 N.m (2.8 kg-m, 20.5 lb-ft)

    Fig 2: Locating Drain Plug & Filler Plug
    G01356833Courtesy of SUZUKI OF AMERICA CORP.

    Hypoid gear oil specification:  API GL-5 SAE 75W-85, 80W-90 or 90

    Fig 3: Oil Viscosity/Temperature Chart
    G01356834Courtesy of SUZUKI OF AMERICA CORP.

    Oil capacity:  2.2 liters (4.6 / 3.9 US / Imp. pt.)