LEMON Manuals: Even more car manuals for everyone
Home >> Suzuki >> 2001 >> XL-7 Limited >> Repair and Diagnosis >> External Pages >> Different car >> Section 144 (Differential & 4WD System) >> Rear >> Rear Differential Dismounting & Remounting >> Dismounting

Rear Differential Dismounting & Remounting: Dismounting

WARNING: This page is about a different car, the 2003 Suzuki Vitara, 2002 Suzuki Vitara, 2001 Suzuki Vitara, 2000 Suzuki Vitara, and 1999 Suzuki Vitara. However, it is still accessible from the selected car via links, so may be relevant.
  1. Lift up vehicle and drain oil from rear differential housing.
  2. Remove rear brake drums and pull out right and left rear axle shafts. See REMOVAL .
  3. Before removing propeller shaft, give match marks (1) on joint flange and propeller shaft as shown.
  4. Remove propeller shaft by removing its 4 flange bolts and nuts.
    Fig 1: Marking Joint Flange & Propeller Shaft
    G01356835Courtesy of SUZUKI OF AMERICA CORP.
  5. Remove differential assembly by removing its 8 fastening nuts (1).
    Fig 2: Removing Differential Assembly
    G01356836Courtesy of SUZUKI OF AMERICA CORP.
scientia non olet · About LEMON Manuals