Inspection steps
WARNING: This page is about a different variant/trim than selected.
NOTE:
ON/OFF status when clutch control solenoid No. 1 (SL2) is normal (Select lever in D position)
| Gear position | 1st | 2nd | 3rd | 4th | 5th | 6th |
|---|---|---|---|---|---|---|
| Clutch control solenoid No. 1 (SL2) | ON | OFF | OFF | ON | OFF | OFF |
- Check of transmission wire unit (clutch control solenoid No. 1 (SL2))
- Disconnect the connector L4 of the transmission wire.
- Measure the resistance between the terminals.STANDARD VALUE RESISTANCE SPECIFICATION
Inspection terminals Inspection conditions Standard value L4-10 (SL2+) - L4-2 (SL2-) 20°C 5.0 to 5.6 Ω L4-10 (SL2+) - chassis ground Always 10 k Ω or more L4-2 (SL2-) - chassis ground Always 10 k Ω or more - Connect the connector L4 of the transmission wire.
NG: Go to Step 4.
OK: Go to next step
- Check wiring harness and connector (transmission wire - transmission control computer ASSY)
- Disconnect the connector A18 of the transmission control computer ASSY.
- Measure the resistance between the terminals. (For terminal arrangement, refer to ECM TERMINAL ARRANGEMENT
.)STANDARD VALUE RESISTANCE SPECIFICATION
Inspection terminals Inspection conditions Standard value A18-5 (SL2+) - A18-11 (SL2-) 20°C 5.0 to 5.6Ω A18-5 (SL2+) - chassis ground Always 10 k Ω or more A18-11 (SL2-) - chassis ground Always 10 k Ω or more - Connect the connector A18 of the transmission control computer ASSY.
NG: Repair or replacement of wiring harness or connector
OK: Go to next step
- Replacement of transmission control computer ASSY
- Replace the transmission control computer ASSY. (Refer to TRANSMISSION CONTROL COMPUTER ASSY )
AT unit correction (refer to WORK SUPPORT )
- Check of clutch control solenoid No. 1 (SL2) unit
- Check the clutch control solenoid No. 1 (SL2) unit. (Refer to UNIT INSPECTION )
NG: Repair or replacement of transmission valve body ASSY (refer to TRANSMISSION VALVE BODY ASSY )
OK: Go to next step
Repair or replacement of transmission wire (refer to TRANSMISSION WIRE )