LEMON Manuals: Even more car manuals for everyone
Home >> Saturn >> 2010 >> Sky Red Line, Standard >> Repair and Diagnosis >> External Pages >> Different variant/trim >> Section 13 (Automatic Transmission - 5L40-E/5L50-E - Repair Instructions - On Vehicle) >> Repair Instructions - On Vehicle >> Pressure Control Solenoid Valve Replacement >> Removal Procedure

Removal Procedure

WARNING: This page is about a different variant/trim than selected.
  1. Remove the transmission fluid pan and filter. Refer to Automatic Transmission Fluid and Filter Replacement .
    2. Fig 1: View Of PCS & Electrical Wiring Harness Connector
    GM795921Courtesy of GENERAL MOTORS CORP.
  2. Disconnect the electrical wiring harness connector (2) from the pressure control solenoid (1).
    3. Fig 2: Locating Solenoid Retainer
    GM795835Courtesy of GENERAL MOTORS CORP.
  3. Using a small screwdriver or pick, remove the pressure control solenoid retainer from the control valve body.
    4. Fig 3: Disassembled View Of Pressure Control Solenoid (PCS)
    GM792778Courtesy of GENERAL MOTORS CORP.
  4. Remove the pressure control solenoid (1) from the control valve body.
  5. Remove the O-ring seals (3-4) from the pressure control solenoid (1), ONLY if the O-rings are cut or worn.
scientia non olet · About LEMON Manuals