LEMON Manuals: Even more car manuals for everyone
Home >> Saturn >> 2004 >> Ion 1 Standard >> Repair and Diagnosis >> Accessories & Equipment >> Gauges & Instrument Panels >> Instrument Panel System Displays, Gauges And Console >> Repair Instructions >> Instrument Panel (I/P) Trim Panel Replacement - Right >> Removal Procedure

Removal Procedure

    CAUTION: Refer to SIR Caution in Cautions and Notices.
  1. Disable the SIR system. Refer to SIR Disabling and Enabling Zone 5 in SIR.
  2. Remove the defroster grille. Refer to Defroster Grille Replacement .
  3. Open the instrument panel (I/P) compartment.
  4. Remove the I/P compartment screws.
  5. Remove the I/P compartment by pulling out on the compartment.
    6. Fig 1: View Of I/P Compartment
    GM877781Courtesy of GENERAL MOTORS CORP.
  6. Remove the bolts from the I/P inflatable restraint module.
    7. Fig 2: View Of I/P Inflatable Restraint Module Bolts
    GM877723Courtesy of GENERAL MOTORS CORP.
  7. Slide the restraint module down and rearward to allow clearance for the I/P trim panel bracket.
  8. Remove the I/P trim panel screws.
    9. Fig 3: View Of Right I/P Trim Panel
    GM877808Courtesy of GENERAL MOTORS CORP.
  9. Push on the upper right corner of the trim panel while lifting up on the lower left corner to release the retaining clips and disengage the trim panel bracket from the I/P retainer.
  10. Pull up on the I/P trim panel in order to remove.
    11. Fig 4: Removing Trim Panel
    GM877834Courtesy of GENERAL MOTORS CORP.
scientia non olet · About LEMON Manuals