LEMON Manuals: Even more car manuals for everyone
Home >> Saturn >> 2002 >> SC2 Automatic, MP6 >> Repair and Diagnosis (Single Page) >> Body & Frame >> Sun Roof/T-Top/Convertible Top >> Roof -- "S" Series >> Repair Instructions >> Sunroof Housing Rear Drain Hose Replacement >> Removal Procedure

Removal Procedure

    Fig 1: Sunroof Front Drain Hose
    GM862959Courtesy of GENERAL MOTORS CORP.
  1. Remove the headliner. Refer to Headlining Trim Panel Replacement (Sedan - 1st Design) or Headlining Trim Panel Replacement (Sedan - 2nd Design) or Headlining Trim Panel Replacement (Wagon - 1st Design) or Headlining Trim Panel Replacement (Wagon - 2nd Design) or Headlining Trim Panel Replacement (Coupe - 1st Design) or Headlining Trim Panel Replacement (Coupe - 2nd Design) in Interior Trim.
  2. Disconnect the sunroof rear drain hose from the sunroof module.
    3. Fig 2: Quarter Panel
    GM864543Courtesy of GENERAL MOTORS CORP.
  3. Remove the appropriate side rear quarter panel. Refer to QUARTER PANEL REPLACEMENT - BOLT ON (WAGON) , QUARTER PANEL REPLACEMENT - BOLT ON (SEDAN) or QUARTER PANEL REPLACEMENT - BOLT ON (COUPE) in Body Rear End article.
    4. Fig 3: Drainhose & Grommet
    GM867361Courtesy of GENERAL MOTORS CORP.
  4. Remove the grommet from the spaceframe.
  5. Disconnect the rear drain hose from the grommet.
  6. Pull the hose out of the spaceframe through the access in the lock pillar area.
scientia non olet · About LEMON Manuals