LEMON Manuals: Even more car manuals for everyone
Home >> Saturn >> 2002 >> SC2 Automatic, MP6 >> Repair and Diagnosis (Single Page) >> Body & Frame >> Exterior Body Panels >> Body Rear End -- "S" Series >> Repair Instructions >> Quarter Panel Replacement - Bolt On (Wagon) >> Removal Procedure

Removal Procedure

    Fig 1: Tail Lamp
    GM867241Courtesy of GENERAL MOTORS CORP.
  1. Remove the rear fascia. Refer to Rear Bumper Fascia Replacement (Coupe) or Rear Bumper Fascia Replacement (Sedan) or Rear Bumper Fascia Replacement (Wagon) in Bumpers.
  2. Remove the tail lamp. Refer to Tail Lamp Replacement (Coupe) or Tail Lamp Replacement (Wagon) or Tail Lamp Replacement (Sedan) in Lighting Systems.
    3. Fig 2: Rear Wheelhouse Panel
    GM865772Courtesy of GENERAL MOTORS CORP.
  3. Remove the rear wheelhouse panel outer plastic fasteners. Refer to Rear Wheelhouse Liner Panel Replacement .
    4. Fig 3: Rocker Panel Cover Fasteners
    GM865443Courtesy of GENERAL MOTORS CORP.
  4. Remove the rear and next 2 plastic fasteners on the rocker panel cover to the lower rear end of the cover.
    5. Fig 4: Left Quarter Panel,
    GM866782Courtesy of GENERAL MOTORS CORP.
  5. If removing the left quarter panel, open the fuel door and remove the latch retainer.
  6. Remove the remaining attaching bolts from the quarter panel.
  7. With all of the bolts removed, pull the rear bottom of the quarter panel outward.
  8. If removing the right quarter panel, remove the quarter panel by sliding backward.
  9. If removing the left quarter panel, remove the quarter panel by pulling up.
scientia non olet · About LEMON Manuals