LEMON Manuals: Even more car manuals for everyone
Home >> Saturn >> 2002 >> SC2 Automatic, MP6 >> Repair and Diagnosis (Single Page) >> Accessories & Equipment >> Gauges & Instrument Panels >> Instrument Panel, Gages, And Console -- "S" Series >> Repair Instructions >> Console Replacement >> Removal Procedure

Removal Procedure

  1. Disable the SIR system. Refer to DISABLING & ACTIVATING AIR BAG SYSTEM in AIR BAG RESTRAINT SYSTEMS article in RESTRAINTS.
  2. Disable the head curtain inflator modules, if equipped. Refer to DISABLING & ACTIVATING AIR BAG SYSTEM in AIR BAG RESTRAINT SYSTEMS article in RESTRAINTS.
  3. Apply the parking brake lever.
    4. Fig 1: Removing Window/Mirror Switch
    GM866358Courtesy of GENERAL MOTORS CORP.
    Fig 2: Switch & Electrical Connectors
    GM866359Courtesy of GENERAL MOTORS CORP.
  4. Remove the power window/mirror switch or storage tray.
    1. Exert pressure on the rear with your hand.
    2. Using a small flat blade screwdriver, carefully lift the switch.
    3. Lift up and out.
    4. Disconnect the electrical connectors by locating the retention tabs and disengaging the connectors.
    5. Fig 3: Locating Console Fasteners
    GM866363Courtesy of GENERAL MOTORS CORP.
  5. Adjust the front seats to the maximum forward position.
  6. Remove the rear console fasteners.
    7. Fig 4: Left And Right Lower Trim Panel Extension
    GM866368Courtesy of GENERAL MOTORS CORP.
  7. Adjust the front seats to the maximum rear position.
  8. Remove the left and right lower trim panel extensions by pulling outward at the dual lock locations.
  9. Rotate the panels outward to disengage the hinges from the console.
    10. Fig 5: Front Console Fasteners
    GM866410Courtesy of GENERAL MOTORS CORP.
  10. Remove the front console fasteners.
  11. Move the console rearward.
  12. Disengage the retaining tabs and disconnect the power outlet connector.
    13. Fig 6: Console & Related Connectors
    GM866413Courtesy of GENERAL MOTORS CORP.
  13. On automatic transaxle equipped vehicles, press and tape the gear selector button IN to clear the shifter opening.
  14. Select neutral for the transaxle gear on automatic transaxles.
  15. Maneuver the console beyond the gear selector and parking brake by lifting the rear of the console.
  16. Remove the console from the vehicle.
scientia non olet · About LEMON Manuals