LEMON Manuals: Even more car manuals for everyone
Home >> Saturn >> 2002 >> SC1 Automatic >> Repair and Diagnosis (Single Page) >> Body & Frame >> Door Locks >> Door System, Mirror System & Window System -- "S" Series >> Repair Instructions >> Secondary Door Seal Replacement - Rear Side Access >> Removal Procedure

Removal Procedure

    Fig 1: Exterior Panel Fasteners
    GM866985Courtesy of GENERAL MOTORS CORP.
  1. Remove lower trim panel. Refer to Rear Side Door Trim Panel Replacement (Coupe)  or Rear Side Door Trim Panel Replacement (Sedan/Wagon) .
  2. Remove lower (3) fasteners of exterior panel.
    3. Fig 2: Push Pins
    GM859292Courtesy of GENERAL MOTORS CORP.
  3. Remove push pins along top and rear of secondary door seal.
  4. Pull seal away from front upper corner.
  5. Remove seal from front edge of door by starting at the front upper corner.
  6. Remove push pin from lower front corner of door.
  7. Remove seal from lower front corner of door.
    8. Fig 3: Push Pins
    GM859308Courtesy of GENERAL MOTORS CORP.
  8. Remove push pins at bottom of door and remove seal. Gently flex the exterior panel to gain access to the lower door latch area. Remove secondary seal.
scientia non olet · About LEMON Manuals