LEMON Manuals: Even more car manuals for everyone
Home >> Porsche >> 2023 >> Taycan Base >> Repair and Diagnosis >> External Pages >> Different car >> Section 164 (46 Brakes - Brake Mechanism 4.0L Turbo Gas -- 971 - PANAMERA (971)) >> WM, 465319 Removing And Installing Rear Brake Disc >> Preliminary Work >> Removing Rear Brake Disc

Removing Rear Brake Disc

WARNING: This page does not describe the selected car, but rather 7 other vehicles, including the 2023 Porsche Panamera, 2022 Porsche Panamera, 2021 Porsche Panamera, 2020 Porsche Panamera, and 2019 Porsche Panamera. However, it is still accessible from the selected car via links, so may be relevant.
NOTE: Removal of brake calliper 
  • Paint defects on brake calliper 

    → Proceed with care when setting back the brake pads.

    → Protect the paintwork on the brake calliper from damage using a suitable cloth.

  1. Select brake pad change mode using > 9900 - PIWIS Tester 3  .
    1. 1.1 Select → 'Brake electronics (PSM, incl. parking brake)'  in the 'Control unit overview'  and press F12 to confirm your selection.
    2. 1.2 Select 'Drive links/checks' → 'Start brake pad change mode'  and start the procedure.
  2. Release and disconnect electric plug connection for brake pad wear indicator -1-  .
    G15862445Courtesy of PORSCHE CARS NORTH AMERICA, INC.

    Electric plug connection for brake pad wear indicator

    Information 

    Do not open the brake hydraulic system.

    Information 

    • Do not use an impact bolter. 
  3. Unscrew screws -arrows-  and loosen the brake calliper from the wheel bearing housing.
    G15862446Courtesy of PORSCHE CARS NORTH AMERICA, INC.

    Loosening brake calliper

  4. Hang the brake calliper at a suitable position in the wheel housing.
  5. Unscrew screws -arrows-  and remove brake disc.
    G15862447Courtesy of PORSCHE CARS NORTH AMERICA, INC.

    Removing brake disc

scientia non olet · About LEMON Manuals