LEMON Manuals: Even more car manuals for everyone
Home >> Porsche >> 2018 >> Cayenne Base >> Repair and Diagnosis >> Engine Mechanical >> Mechanical >> 10 - Engine - Crankcase, Suspension -- 92AAB1 Cayenne S (3.6L) >> WM, 100119 Removing And Installing Engine >> Preliminary Work

Preliminary Work

  1. Read out the DME fault memory.

    > 0101IN DIAGNOSTIC SYSTEM: READING OUT FAULT MEMORY AND ACTIVATING SYSTEMS

  2. For vehicles with air suspension:

    Move air suspension into service position.

    > WM 4301IN BLEEDING AND FILLING THE LEVELLING SYSTEM (CAYENNE, CAYENNE GTS, CAYENNE TURBO S, CAYENNE S, CAYENNE S E-HYBRID, CAYENNE TURBO, CAYENNE S DIESEL, CAYENNE (3.0))

  3. Remove engine guard with transverse strut.

    > 108019 REMOVING AND INSTALLING ENGINE GUARD 

  4. For vehicles with 19-inch brake system: Remove air guide at the anti-roll bar.

    > WM 407719 REMOVING AND INSTALLING FRONT ANTI-ROLL BAR (PDCC) (CAYENNE, CAYENNE GTS, CAYENNE TURBO S, CAYENNE S, CAYENNE TURBO)

  5. Disconnect the battery.

    > WM 2X00IN WORK INSTRUCTIONS AFTER DISCONNECTING THE BATTERY (CAYENNE S, CAYENNE S E-HYBRID, CAYENNE TURBO, CAYENNE (3.0))

  6. Remove front wheels.

    > WM 440519 REMOVING AND INSTALLING WHEEL (EXCEPT CAYENNE, CAYENNE GTS, CAYENNE TURBO S, CAYENNE S HYBRID, CAYENNE S E, CAYENNE TURBO, CAYENNE S DIESEL, CAYENNE (3.0))

  7. Remove the front wheel housing liners.

    > WM 505619 REMOVING AND INSTALLING FRONT WHEEL HOUSING LINER

  8. Move bonnet into service position.

    > WM 553119 REMOVING AND INSTALLING FRONT PNEUMATIC SPRING (CAYENNE, CAYENNE GTS, CAYENNE TURBO S, CAYENNE S, CAYENNE S E-HYBRID, CAYENNE TURBO, CAYENNE S DIESEL, CAYENNE (3.0))

    1. > 9704 - Bonnet stay  must be used.
  9. Remove engine cover.
  10. Remove engine compartment trim panels.

    > WM 700219 REMOVING AND INSTALLING FRONT TRIM PANEL (ENGINE COMPARTMENT) (CAYENNE, CAYENNE GTS, CAYENNE TURBO S, CAYENNE S, CAYENNE S E-HYBRID, CAYENNE TURBO, CAYENNE S DIESEL, CAYENNE (3.0))

  11. Remove torque support.

    > 103719 REMOVING AND INSTALLING TORQUE SUPPORT 

  12. Remove upper part of air cleaner on both sides.

    > WM 242519 REMOVING AND INSTALLING AIR CLEANER HOUSING (CAYENNE S, CAYENNE TURBO, CAYENNE GTS & CAYENNE TURBO S)

  13. Drain coolant.

    > WM 193817 DRAINING AND FILLING COOLANT (CAYENNE GTS, CAYENNE S, CAYENNE TURBO & CAYENNE TURBO S)

  14. Extract refrigerant from the air conditioning system.

    > WM 870317 DRAINING AND FILLING REFRIGERANT (CAYENNE, CAYENNE GTS, CAYENNE TURBO S, CAYENNE S, CAYENNE S E-HYBRID, CAYENNE TURBO, CAYENNE S DIESEL, CAYENNE (3.0))

scientia non olet · About LEMON Manuals