LEMON Manuals: Even more car manuals for everyone
Home >> Porsche >> 2017 >> Panamera Base >> Repair and Diagnosis >> External Pages >> Different car >> Section 36 (66 Exterior Equipment - Wagon -- 971 - PANAMERA (971)) >> WM, 66581530 Adjusting Rear Spoiler >> Adjusting Rear Spoiler (Wing)

Adjusting Rear Spoiler (Wing)

WARNING: This page does not describe the selected car, but rather 6 other vehicles, including the 2023 Porsche Panamera, 2022 Porsche Panamera, 2021 Porsche Panamera, 2020 Porsche Panamera, and 2019 Porsche Panamera. However, it is still accessible from the selected car via links, so may be relevant.
  1. Check gap dimensions.

    > 5X00IN Gap dimensions 

    > Gap dimension 4 mm +/- 0.7 mm 

    > Gap dimension 3.5 mm +/- 0.5 mm 

    > Gap dimension 0.5 mm +/- 0.5 mm 

    > Gap dimension 3.5 mm +/- 0.8 mm 

    > Gap dimension 0.5 mm +/- 0.5 mm 

    > Gap dimension 3.5 mm +/- 0.5 mm 

    > Gap dimension 0.5 mm - 0.3 mm +/- 0.4 mm 

  2. For adapting the gap dimensions in X and Y direction.
    G15866269Courtesy of PORSCHE CARS NORTH AMERICA, INC.

    Rear spoiler (wing)

    1. 2.1 Extend rear spoiler fully using PIWIS Tester III. 
    2. 2.2 Loosen screws -1-  until the rear spoiler (wing) can still be moved.
    3. 2.3 Retract rear spoiler (wing) fully using PIWIS Tester III. 
    4. 2.4 Adjust rear spoiler (wing).
    5. 2.5 Check gap dimensions.
    6. 2.6 Extend rear spoiler (wing) fully using PIWIS Tester III. 
    7. 2.7 Tighten screws to > Tightening torque 6 Nm (4.4 ftlb.)  .
  3. For adapting the gap dimensions in Z direction.
    G15866270Courtesy of PORSCHE CARS NORTH AMERICA, INC.

    Rear spoiler (wing)

    1. 3.1 Mark position of rear spoiler (wing) -1-  .
      G15866271Courtesy of PORSCHE CARS NORTH AMERICA, INC.

      Rear spoiler (wing) position

    2. 3.2 Loosen screws -1-  until the shims -2-  can be removed.
      G15866272Courtesy of PORSCHE CARS NORTH AMERICA, INC.

      Rear spoiler (wing)

    3. 3.3 Replace shims -2-  with corresponding shims from repair kit 974.898.037. 
      G15866273Courtesy of PORSCHE CARS NORTH AMERICA, INC.

      Rear spoiler (wing)

      Information 

      Always replace self-locking screws.

    4. 3.4 Position rear spoiler (wing) -1-  and tighten screws until the rear spoiler (wing) can still be moved.
      G15866274Courtesy of PORSCHE CARS NORTH AMERICA, INC.

      Rear spoiler (wing) position

    5. 3.5 Retract rear spoiler (wing) fully using PIWIS Tester III. 
    6. 3.6 Check gap dimensions.
    7. 3.7 Extend rear spoiler (wing) fully using PIWIS Tester III. 
    8. 3.8 Tighten screws to > Tightening torque 6 Nm (4.4 ftlb.)  .
scientia non olet · About LEMON Manuals