LEMON Manuals: Even more car manuals for everyone
Home >> Porsche >> 2016 >> Macan Turbo >> Repair and Diagnosis >> External Pages >> Different car >> Section 736 (Fuel Tank & Lines - V6 S/C 3.0L Petrol -- Discovery/L462) >> Fuel Tank And Lines - V6 S/C 3.0L Petrol >> Removal And Installation >> Fuel Tank >> Removal

Fuel Tank: Removal

WARNING: This page is about a different car, the 2018 Land Rover Discovery and 2017 Land Rover Discovery. However, it is still accessible from the selected car via links, so may be relevant.
WARNING:
  • After completing repairs, the fuel system must be checked visually for leaks. Failure to follow these instructions may result in personal injury.
  • This procedure involves fuel handling. Be prepared for fuel spillage at all times and always observe fuel handling precautions. Failure to follow these instructions may result in personal injury.
  • The spilling of fuel is unavoidable during this operation. Make sure that all necessary precautions are taken to prevent fire and explosion.
  • If fuel contacts the eyes, flush the eyes with cold water or eyewash solution and seek medical attention.
NOTE: This procedure contains some variation in the illustrations depending on the vehicle specification, but the essential information is always correct.

All vehicles 

  1. Raise and support the vehicle on a suitable 2 post lift.

    Refer to: JACKING AND LIFTING

  2. Before working on the fuel system make sure to study the fuel system health and safety section.

    Refer to: PETROL AND PETROL-ETHANOL FUEL SYSTEMS HEALTH AND SAFETY PRECAUTIONS .

  3. Disconnect the startup battery ground cable.

    Refer to: SPECIFICATIONS .

  4. Drain the fuel tank.

    Refer to: FUEL TANK DRAINING .

  5. NOTE: Repeat the step for the other side.

    Remove the rear rocker panel moulding.

    Refer to: REAR ROCKER PANEL MOULDING .

  6. Remove the rear driveshaft.

    Refer to: REAR DRIVESHAFT - V6 S/C 3.0L PETROL .

  7. NOTE:
    • This step contains illustrations for left side components, right side components are similar.
    • Repeat the step for the other side.
    G11692874
    • Remove the 5 bolts.
    • Remove the 7 bolts.
    • Remove the undershield.

    Vehicles with fuel fired booster heater 

  8. WARNING: Be prepared to collect escaping fuel.
    G12000167

    Disconnect the fuel line.

    All vehicles 

  9. WARNING: Be prepared to collect escaping fuel.
    G11708437

    Disconnect the 2 fuel lines.

  10. NOTE:
    • Do not disassemble further if the component is removed for access only.
    • This step requires the aid of another technician.
    G12000169
    • Release the hose clamp.
    • Release the fuel hose.
    • Remove the 7 bolts.
    • Remove the fuel tank assembly.
  11. G12000170
    • Release the 4 clips.
    • Remove the fuel hose assembly.
    • Remove the 5 bolts.
    • Remove the fuel tank lower cover.
  12. G12000171
    • Disconnect the fuel line.
    • Remove the fuel pump assembly.
    • Remove the fuel level sensor and bracket assembly.
scientia non olet · About LEMON Manuals