LEMON Manuals: Even more car manuals for everyone
Home >> Porsche >> 2016 >> 911 Turbo, 2D Convertible >> Repair and Diagnosis >> External Pages >> Different car >> Section 113 (19 - Engine - Cooling -- CARRERA (997)) >> WM 194019 Removing And Installing Coolant Tank (Turbo Coupe, Turbo CABRIO & Gt2) >> Installing Coolant Tank >> Installing Reservoir For Coolant

Installing Reservoir For Coolant

WARNING: This page does not describe the selected car, but rather 9 other vehicles, including the 2013 Porsche 911, 2012 Porsche 911, 2011 Porsche 911, 2010 Porsche 911, and 2009 Porsche 911. However, it is still accessible from the selected car via links, so may be relevant.
WARNING: Caustic fluids
  • Danger of chemical burns

→ Avoid contact with caustic fluid.

→ Wear personal protective gear.

→ Ensure that there is good ventilation.

→ If you do come into contact, wash off immediately with plenty of warm water and contact a doctor if necessary.

  1. Install coolant reservoir.
    1. 1.1. Guide reservoir into the engine compartment and slide it into the holders.
    2. 1.2. Screw in and tighten the collar nut.

      → Tightening torque: 10 Nm (7.5 ft. lb.) 

  2. Install engine coolant level sensor -2-  .

    Insert the sensor -2-  into the reservoir and connect the cable plug.

    Fig 1: Installing Engine Coolant Level Sensor
    G09827718Courtesy of PORSCHE CARS NORTH AMERICA, INC.

    Information 

    To facilitate assembly of coolant pipes and hoses, smear with Kluberplus S06-100 assembly gel.

  3. Install coolant hoses.
    1. 3.1. Check the O-ring on the large coolant hose -2-  for damage and replace it if necessary. Fit spring clamps on the mounts.
    2. 3.2. Press the coolant hose -2-  firmly into the mounts. The coolant hose must lock with an audible click in both connection pieces. Pull to check that the connection is secure.
      Fig 2: Identifying Coolant Hoses And Reservoir Installation Position
      G09827719Courtesy of PORSCHE CARS NORTH AMERICA, INC.
    3. 3.3. Install supply hose -3-  . Attach the hose and tighten the spring band clamp.
      Fig 3: Identifying Coolant Supply Hose And Left Henn Coupling
      G09827720Courtesy of PORSCHE CARS NORTH AMERICA, INC.
  4. Fit coolant hoses at the coolant reservoir -1-  .
    1. 4.1. Connect the supply hose from the radiator -2-  to the coolant reservoir and clip it in at the holder.
    2. 4.2. Connect the overflow hose -3-  to the coolant reservoir.
      Fig 4: Identifying Reservoir Coolant Hoses
      G09827721Courtesy of PORSCHE CARS NORTH AMERICA, INC.