LEMON Manuals: Even more car manuals for everyone
Home >> Porsche >> 2001 >> 911 Turbo, Automatic >> Repair and Diagnosis >> Brakes >> Mechanical - Hydraulic >> Brakes - Mechanical - 911 Turbo (996) >> Removing and installing the front disc brake pads - GT2 / Turbo with PCCB >> Removal

Removing and installing the front disc brake pads - GT2 / Turbo with PCCB: Removal

CAUTION: PCCB (Porsche Ceramic Composite Brake): Danger of material damage during wheel removal/installation (danger of damage to brake discs)! Use assembly aids (assembly pins) in order to exclude any possibility of heavy contact of the wheel with the brake disc! The assembly aids (2 assembly pins) are located in the luggage compartment!
  1. Screw the 2 assembly aids (assembly pins), instead of 2 wheel bolts, into the wheel hub before wheel removal/installation. During removal, first remove the three remaining wheel bolts and remove the wheel carefully, without touching the brake discs.
    Fig 1: Screwing 2 Assembly Aids (Assembly Pins) Into The Wheel Hub
    G03093908Courtesy of PORSCHE OF NORTH AMERICA, INC.
  2. Undo the screw on the retaining pin. Counter the retaining pin when doing this.
    Fig 2: Removing Screw On Retaining Pin
    G03093909Courtesy of PORSCHE OF NORTH AMERICA, INC.
  3. Pull out the retaining pin towards the inside.
    Fig 3: Pulling Out Retaining Pin
    G03093910Courtesy of PORSCHE OF NORTH AMERICA, INC.
  4. Pull out the warning contact wire on the brake caliper and remove the warning contacts from the brake pad plates.
    NOTE:
    • Replace warning contacts if the core of the wire is worn or worn through!
    • The warning contact can continue to be used if there are only scrape marks on the plastic part of the warning contact!
    • If necessary, remove some brake fluid by suction from the brake fluid reservoir (brake fluid may escape over the rim of the container)!
  5. Set back the brake pads as far as possible with the piston resetting fixture (press back)!
  6. Pull out brake pads together with the damper plates (remove). If this is not possible (depending on wear of the brake pads), use a spatula to detach the damper plates from the brake pad backing plate before removing the pads.
    Fig 4: Pulling Out Brake Pads Together With Damper Plates
    G03093911Courtesy of PORSCHE OF NORTH AMERICA, INC.