LEMON Manuals: Even more car manuals for everyone
Home >> Pontiac >> 2008 >> Torrent GXP, AWD >> Repair and Diagnosis >> External Pages >> Different car >> Section 155 (Engine Mechanical - 3.4L) >> Repair Instructions - Off Vehicle >> Valve Rocker Arm Cover Removal - Left Side

Valve Rocker Arm Cover Removal - Left Side

WARNING: This page is about a different car, the 2009 Pontiac Torrent and 2009 Chevrolet Equinox. However, it is still accessible from the selected car via links, so may be relevant.
    Fig 1: View Of Foul Air Tube
    GM1369207Courtesy of GENERAL MOTORS CORP.
  1. Remove the foul air tube bolt (535) and the clip (534).
  2. Remove the foul air tube (533).
    3. Fig 2: View Of Valve Rocker Arm Cover - Left
    GM54369Courtesy of GENERAL MOTORS CORP.
    CAUTION: Valve rocker arm cover gasket and sealant must be carefully trimmed away from lower intake manifold gasket. Failure to do so will damage the lower intake manifold gasket, causing a severe oil leak.
    NOTE: When removing the valve rocker arm cover make sure the gasket stays in place attached to the cylinder head.
  3. Remove the valve rocker arm cover bolts.
  4. Remove the valve rocker arm cover.
  5. Remove and discard the valve rocker arm cover gasket, valve rocker arm cover grommets and valve rocker arm cover bolts if they are serviced with the grommet.
    6. Fig 3: Identifying Cylinder Head To Lower Intake Manifold Joint
    GM190588Courtesy of GENERAL MOTORS CORP.
  6. Trim valve cover gasket and sealant away from lower intake manifold gasket at the cylinder head to lower intake manifold joints (1).
  7. Remove the valve rocker arm cover gasket.
scientia non olet · About LEMON Manuals