Rattle, Clunk, or Shudder Noise from the Power Steering System (with HPS)
WARNING: This page is about a different car, the 2009 Pontiac Torrent and 2009 Chevrolet Equinox. However, it is still accessible from the selected car via links, so may be relevant.
| Step | Action | Yes | No |
|---|---|---|---|
| 1 | Did you review the Power Steering System General Description and perform the necessary inspections? | Go to Step 2 | Go to Symptoms - Power Steering System (with HPS) or Symptoms - Power Steering System (with EPS) |
| 2 | Verify that a rattle, clunk or shudder noise is present. Is a rattle, clunk or shudder noise present? |
Go to Step 3 | System OK |
| 3 | Inspect the power steering hoses for proper routing and clearance. Is the routing or clearance of the power steering hoses incorrect? |
Go to Step 11 | Go to Step 4 |
| 4 | Inspect the engine drive belt for cracking or excessive wear. Refer to Drive Belt Falls Off and Excessive Wear Diagnosis
. Is the drive belt cracked or excessively worn? |
Go to Step 12 | Go to Step 5 |
| 5 | Inspect the power steering pump pulley for damage. Is the power steering pump pulley damaged? |
Go to Step 13 | Go to Step 6 |
| 6 | Inspect the power steering pump and the power steering mounting bracket/brace for the proper installation. Refer to Power Steering Pump Replacement . Is the power steering pump installation incorrect? |
Go to Step 14 | Go to Step 7 |
| 7 | Inspect the power steering gear for the proper installation. Refer to Steering Gear Replacement (Electronic Power Steering) or Steering Gear Replacement (Hydraulic Power Steering) . Is the power steering gear installation incorrect? |
Go to Step 15 | Go to Step 8 |
| 8 | Inspect for looseness in the inner and outer tie rod ends. Did you find looseness in the tie rod ends? |
Go to Step 16 | Go to Step 9 |
| 9 | Inspect the suspension. Is the suspension worn? |
Go to Step 17 | Go to Step 10 |
| 10 | Inspect the intermediate shaft. Is the intermediate shaft worn? |
Go to Step 18 | Go to Step 3 |
| 11 | Adjust or replace the hoses. Refer to the appropriate procedure(s):
Did you complete the repair? |
Go to Step 19 | - |
| 12 | Replace the engine drive belt. Refer to Drive Belt Replacement
. Did you complete the repair? |
Go to Step 19 | - |
| 13 | Replace the power steering pump pulley. Refer to Power Steering Pump Pulley Replacement . Did you complete the repair? |
Go to Step 19 | - |
| 14 | Install the power steering pump correctly. Refer to Power Steering Pump Replacement . Did you complete the repair? |
Go to Step 19 | - |
| 15 | Install the power steering gear correctly. Refer to Steering Gear Replacement (Electronic Power Steering) or Steering Gear Replacement (Hydraulic Power Steering) . Did you complete the repair? |
Go to Step 19 | - |
| 16 | Replace the tie rod end. Refer to Steering Linkage Inner Tie Rod Replacement - Off Vehicle . Did you complete the repair? |
Go to Step 19 | - |
| 17 | Replace the worn suspension components. Refer to Diagnostic Starting Point - Suspension General Diagnosis
. Did you complete the repair? |
Go to Step 19 | - |
| 18 | Replace the intermediate shaft. Refer to Intermediate Steering Shaft Replacement
. Did you complete the repair? |
Go to Step 19 | - |
| 19 | Operate the system in order to verify the repair. Did you correct the condition? |
System OK | Go to Step 3 |