LEMON Manuals: Even more car manuals for everyone
Home >> Pontiac >> 2008 >> Grand Prix GXP >> Repair and Diagnosis >> External Pages >> Different variant/trim >> Section 1 (Engine Controls And Fuel - 3.8L - Introduction (2 Of 2)) >> Repair Instructions >> Fuel Hose/Pipes Assembly Replacement >> Removal Procedure

Removal Procedure

WARNING: This page is about a different variant/trim than selected.
IMPORTANT: Clean the fuel connections and surrounding areas prior to disconnecting the lines in order to avoid possible system contamination.
    Fig 1: Evaporative Emission (EVAP) Line
    GM1575496Courtesy of GENERAL MOTORS CORP.
  1. Remove the air cleaner intake duct. Refer to Air Cleaner Inlet Duct Replacement .
  2. Remove the brake master cylinder and reposition. Refer to Master Cylinder Replacement .
  3. Relieve the fuel system. Refer to Fuel Pressure Relief (With CH 48027)  or Fuel Pressure Relief (Without CH 48027) .
  4. Disconnect the fuel feed line (1) from the fuel rail. Refer to Metal Collar Quick Connect Fitting Service .
    5. Fig 2: Fuel/Brake Pipe Retainers
    GM1555269Courtesy of GENERAL MOTORS CORP.
  5. Open the fuel/brake pipe retainers (1).
  6. Remove the fuel feed line from the fuel/brake pipe retainers (1).
  7. Raise and support the vehicle. Refer to Lifting and Jacking the Vehicle .
    8. Fig 3: Fuel/Brake Line Retainer Bolt
    GM1555271Courtesy of GENERAL MOTORS CORP.
  8. Remove the fuel/brake line retainer bolt.
  9. Remove the fuel feed line from the retainer.
    10. Fig 4: Fuel/Brake Line Push In Retainer
    GM1555273Courtesy of GENERAL MOTORS CORP.
  10. Remove the fuel/brake line push in retainer from the underbody.
  11. Remove the fuel feed line from the retainer.
    12. Fig 5: Fuel/Brake Pipe Retainer Bolts
    GM1555275Courtesy of GENERAL MOTORS CORP.
  12. Remove the fuel/brake line retainer bolts.
  13. Remove the fuel feed line from the retainer.
    14. Fig 6: Rear Fuel/Brake Pipe Retainer
    GM1555277Courtesy of GENERAL MOTORS CORP.
  14. Open the fuel/brake line retainer (1).
  15. Remove the fuel feed line from the retainer.
    16. Fig 7: View Of Fuel Feed, EVAP and Fuel Tank Lines
    GM1554561Courtesy of GENERAL MOTORS CORP.
  16. Disconnect the fuel feed (3) and evaporative emission (EVAP) (4) lines from the fuel tank lines (1, 2). Refer to Plastic Collar Quick Connect Fitting Service .
  17. Remove the fuel feed line.
scientia non olet · About LEMON Manuals