LEMON Manuals: Even more car manuals for everyone
Home >> Pontiac >> 2008 >> G5 Base, Automatic >> Repair and Diagnosis >> Body & Frame >> Exterior Body Panels >> Bolted Exterior Body Panels And Closures >> Repair Instructions >> Rear Side Door Replacement

Rear Side Door Replacement

Fig 1: View Of Rear Side Door Hinges & Bolts
GM1548968Courtesy of GENERAL MOTORS CORP.
Callout Component Name
CAUTION: Refer to SIR Caution .

Preliminary Procedures

  1. Disable the supplemental inflatable restraint (SIR) system. Refer to SIR Disabling and Enabling .
  2. Remove the rear door trim panel. Refer to Rear Side Door Trim Panel Replacement .
1 Rear Side Door Hinge Upper Bolt (Qty: 2)
NOTE: Refer to Fastener Notice .

Procedure

  1. Remove the water deflector.
  2. Support the door before removing the hinge bolts.
  3. Disconnect the electrical connector, if equipped.
  4. With the aid of an assistant, remove the door.

Tighten:  35 N.m (26 lb ft)
2 Rear Side Door Check Link Bolt

Tighten:  20 N.m (15 lb ft)
3 Rear Side Door Hinge Lower Bolt (Qty: 2)

Tighten:  35 N.m (26 lb ft)
4 Rear Side Door Assembly
Procedure: 
When replacing the door it is necessary to transfer all of the internal components.
scientia non olet · About LEMON Manuals