LEMON Manuals: Even more car manuals for everyone
Home >> Pontiac >> 2007 >> Solstice GXP, Standard >> Repair and Diagnosis >> External Pages >> Different variant/trim >> Section 3 (Engine Mechanical - 2.4L) >> Repair Instructions >> On-Vehicle Repair Instructions >> Engine Mount Bracket Replacement - Left Side >> Installation Procedure

Installation Procedure

WARNING: This page is about a different variant/trim than selected.
    Fig 1: Engine Mount Bracket Bolts And Bracket
    GM1592520Courtesy of GENERAL MOTORS CORP.
  1. Position the left engine mount bracket to the engine block.
  2. Install the left engine mount bracket bolts until snug.
    NOTE: Refer to Fastener Notice .
  3. Tighten the left engine mount bracket bolts.

    Tighten:  Tighten the bolts in the sequence shown to 55 N.m (41 lb ft).

    4. Fig 2: Engine Harness Electrical Connector
    GM1590505Courtesy of GENERAL MOTORS CORP.
  4. Install the positive battery cable terminal (5) to the generator.
  5. Install the generator positive battery cable nut (2) to the generator.

    Tighten:  Tighten the nut to 20 N.m (15 lb ft).

  6. Position the positive battery cable boot (4).
    7. Fig 3: Engine Harness Clip
    GM1590535Courtesy of GENERAL MOTORS CORP.
  7. Install the engine harness clip (4) to the intake manifold.
    8. Fig 4: Engine Harness Tie Straps & Cable Clips
    GM1592511Courtesy of GENERAL MOTORS CORP.
  8. Install the positive battery cable terminal (5) to the starter.
  9. Install the starter solenoid positive battery cable nut (4) to the starter.

    Tighten:  Tighten the nut to 10 N.m (89 lb in).

  10. Install the tire and wheel. Refer to Tire and Wheel Removal and Installation .
  11. Install the left engine mount. Refer to Engine Mount Replacement - Left Side .
scientia non olet · About LEMON Manuals