LEMON Manuals: Even more car manuals for everyone
Home >> Pontiac >> 2007 >> Grand Prix GXP >> Repair and Diagnosis >> Body & Frame >> Exterior Body Panels >> Bolted Exterior Body Panels & Closures >> Repair Instructions >> Front Side Door Hinge Replacement >> Removal Procedure

Removal Procedure

    NOTE: Refer to Paint Damage Notice .
  1. Apply masking tape to the fender and door edges.
    2. IMPORTANT: Do not remove the door from the vehicle to replace the upper or lower hinges.
  2. Open and support the door.
  3. Clean the area around the hinge and mark the location with a grease pencil.
    4. Fig 1: Door Side Hinge Bolts (Front Door)
    GM800994Courtesy of GENERAL MOTORS CORP.
  4. If the upper hinge is broken do the following:

    Remove the upper hinge bolts from the door side in the specified sequence (1, 4).

    5. Fig 2: Upper Hinge Bolts At Hinge Pillar Side (Front Door)
    GM800993Courtesy of GENERAL MOTORS CORP.
  5. Remove the upper hinge bolts from the hinge pillar side in the specified sequence (1, 4, 5).
    6. Fig 3: Door Side Hinge Bolts (Front Door)
    GM800994Courtesy of GENERAL MOTORS CORP.
  6. If the lower hinge is broken do the following:

    Remove the lower hinge bolts from the door side in the specified sequence (3, 2).

    7. Fig 4: Upper Hinge Bolts At Hinge Pillar Side (Front Door)
    GM800993Courtesy of GENERAL MOTORS CORP.
  7. Remove the lower hinge bolts from the hinge pillar side in the specified sequence (3, 2).
  8. Remove the broken hinge from the door.
scientia non olet · About LEMON Manuals