LEMON Manuals: Even more car manuals for everyone
Home >> Pontiac >> 2002 >> Aztek FWD >> Repair and Diagnosis (Single Page) >> Body & Frame >> Sun Roof/T-Top/Convertible Top >> Power Sun Roof >> Repair Instructions >> Sunroof Glass Height and Opening Fit Adjustment

Sunroof Glass Height and Opening Fit Adjustment

  1. Slide the sunroof sunshade to the open position.
  2. Adjust the sunroof glass panel to the fully closed position.
  3. Separately loosen the 6 sunroof glass panel screws (3 each side).
  4. Individually adjust the 4 corners of the sunroof glass panel.
  5. Adjust the front of the sunroof glass panel to 2.0 mm (0.079 in) below the top surface of the roof panel.
  6. Adjust the rear of the sunroof glass panel to 2 mm (1/8 in) above the top surface of the roof panel.
    Fig 1: View Of Sunroof
    G01722401Courtesy of GENERAL MOTORS CORP.
    NOTE: Refer to FASTENER NOTICE .
  7. Tighten the sunroof glass panel screws.

    Tighten 

    Tighten the sunroof glass panel screws to 4 N.m (35 lb in).

scientia non olet · About LEMON Manuals