LEMON Manuals: Even more car manuals for everyone
Home >> Opel >> 1969 >> Rallye 1.1L Eng >> Repair and Diagnosis (Single Page) >> Engine Mechanical >> Mechanical >> OPEL Engines >> 1966-71 OPEL 1.1 Liter 4 Cylinder >> Engine Removal >> All Exc. 1970 GT

All Exc. 1970 GT

  1. Remove hood and disconnect battery cables. Drain cooling system and remove assembly including hoses. Using suitable tool (J-21709) remove shift linkage. Remove air cleaners. Withdraw throttle rod from carburetor and rear support.
  2. From engine, disconnect fuel line, control cables for carburetors and heater, heater hoses and starter wires, alternator, distributor, and back-up light switch on transmission.
  3. Remove oil filter and its housing. Disconnect exhaust pipe from exhaust manifold. Raise car and support in safe manner. Remove drive shaft.
  4. Support transmission with a jack. Attach suitable lift to engine. Remove transmission to crankcase bolts. Extract transmission mounting bolts. Remove engine mounts from each side of engine. Lift engine from car.
scientia non olet · About LEMON Manuals