LEMON Manuals: Even more car manuals for everyone
Home >> Nissan-Datsun >> 2021 >> NV2500 HD S >> Repair and Diagnosis >> External Pages >> Different car >> Section 501 (Engine Control System (DTC/Circuit Diagnosis) (2 Of 3)) >> DTC/Circuit Diagnosis >> DTC P0303: Misfire >> DTC Diagnosis Procedure

DTC Diagnosis Procedure

WARNING: This page is about a different car, the 2019 Nissan NV3500 HD, 2019 Nissan NV2500 HD, and 2019 Nissan NV1500. However, it is still accessible from the selected car via links, so may be relevant.
  1. CHECK GROUND CONNECTION 

    Check the following.

    • Connection condition of the ground F10 and F16
    • Connection condition of the ground harness between the engine assembly and vehicle body (if equipped)

    Is the inspection result normal?

    YES

    GO TO 2.

    NO

    Repair or replace the error-detected parts.

  2. CHECK FOR INTAKE AIR LEAK AND PCV HOSE 
    1. Start the engine and run it at idle speed.
    2. Listen for the sound of the intake air leak.
    3. Check PCV hose connection.

    Is intake air leak detected?

    YES

    Discover air leak location and repair.

    NO

    GO TO 3.

  3. CHECK FOR EXHAUST SYSTEM CLOGGING 

    Stop the engine and visually check exhaust tube, three way catalyst and muffler for dents.

    Is the inspection result normal?

    YES

    SYMBOL With CONSULT: GO TO 4.

    YES

    SYMBOL Without CONSULT: GO TO 5.

    NO

    Repair or replace it.

  4. PERFORM POWER BALANCE TEST 

    SYMBOL With CONSULT

    1. Start the engine.
    2. Perform "POWER BALANCE" in "ACTIVE TEST" mode of "ENGINE" using CONSULT.
    3. Make sure that each circuit produces a momentary engine speed drop.

    Is the inspection result normal?

    YES

    GO TO 10.

    NO

    GO TO 5.

  5. CHECK FUNCTION OF FUEL INJECTOR 
    1. Start the engine and let it idle.
    2. Listen to each fuel injector operation sound.
      G04132840Courtesy of NISSAN NORTH AMERICA, INC.

      Clicking sound should be heard.

    Is the inspection result normal?

    YES

    GO TO 6.

    NO

    Perform trouble diagnosis for FUEL INJECTOR, refer to DTC Diagnosis Procedure .

  6. CHECK FUNCTION OF IGNITION COIL-1 
    CAUTION: Perform the following procedure in a place where with no combustible objects and good ventilation.
    1. Turn ignition switch OFF.
    2. Remove fuel pump fuse (#48) in IPDM E/R to release fuel pressure.
      GNSALBIA0738Z-738Courtesy of NISSAN NORTH AMERICA, INC.

      1.

      Fuel pump fuse

      2.

      IPDM E/R

      NOTE: Do not use CONSULT to release fuel pressure, or fuel pressure applies again during the following procedure.
    3. Start the engine.
    4. After the engine stalls, crank it two or three times to release all fuel pressure.
    5. Turn ignition switch OFF.
    6. Remove all ignition coil harness connectors to avoid the electrical discharge from the ignition coils.
    7. Remove ignition coil and spark plug of the cylinder to be checked.
    8. Crank the engine for 5 seconds or more to remove combustion gas in the cylinder.
    9. Connect spark plug and harness connector to ignition coil.
    10. Fix ignition coil using a rope etc. with gap of 13 - 17 mm (0.52 - 0.66 in) between the edge of the spark plug and grounded metal portion as shown in the figure.
      G04886523Courtesy of NISSAN NORTH AMERICA, INC.
    11. Crank the engine for about 3 seconds, and check whether spark is generated between the spark plug and the grounded metal portion.

      Spark should be generated.

      CAUTION:
      • Never place the spark plug and the ignition coil within 50 cm (19.7 in) each other. Be careful not to get an electrical shock while checking, because the electrical discharge voltage becomes 20 kV or more.
      • It might damage the ignition coil if the gap of more than 17 mm (0.66 in) is made.
      NOTE: When the gap is less than 13 mm (0.52 in), a spark might be generated even if the coil is malfunctioning.

    Is the inspection result normal?

    YES

    GO TO 10.

    NO

    GO TO 7.

  7. CHECK FUNCTION OF IGNITION COIL-2 
    1. Turn ignition switch OFF.
    2. Disconnect spark plug and connect a non-malfunctioning spark plug.
    3. Crank the engine for about 3 seconds, and recheck whether spark is generated between the spark plug and the grounded metal portion.

      Spark should be generated.

    Is the inspection result normal?

    YES

    GO TO 8.

    NO

    Check ignition coil, power transistor and their circuits. Refer to DTC Diagnosis Procedure .

  8. CHECK SPARK PLUG 

    Check the initial spark plug for fouling, etc.

    G04185314Courtesy of NISSAN NORTH AMERICA, INC.

    Is the inspection result normal?

    YES

    Replace spark plug(s) with standard type one(s). For spark plug type, refer to Removal and Installation .

    NO

    Repair or clean spark plug. Then GO TO 9.

  9. CHECK FUNCTION OF IGNITION COIL-3 
    1. Reconnect the initial spark plugs.
    2. Crank the engine for about 3 seconds, and recheck whether spark is generated between the spark plug and the grounded portion.

      Spark should be generated.

    Is the inspection result normal?

    YES

    INSPECTION END

    NO

    Replace spark plug(s) with standard type one(s). For spark plug type, refer to Removal and Installation .

  10. CHECK COMPRESSION PRESSURE 

    Check compression pressure. Refer to Compression Pressure .

    Is the inspection result normal?

    YES

    GO TO 11.

    NO

    Check pistons, piston rings, valves, valve seats and cylinder head gaskets.

  11. CHECK FUEL PRESSURE 
    1. Install all removed parts.
    2. Release fuel pressure to zero. Refer to Work Procedure .
    3. Install fuel pressure gauge and check fuel pressure. Refer to Work Procedure .

      At idle: Approximately 350 kPa (3.57 kg/cm 2 , 51 psi)

    Is the inspection result normal?

    YES

    GO TO 13.

    NO

    GO TO 12.

  12. DETECT MALFUNCTIONING PART 

    Check fuel hoses and fuel tubes for clogging.

    Is the inspection result normal?

    YES

    Replace "fuel filter and fuel pump assembly". Refer to Removal and Installation - VQ40DE .

    NO

    Repair or replace.

  13. CHECK IDLE SPEED AND IGNITION TIMING 

    For procedure, refer to Work Procedure .

    For specification, refer to Idle Speed and Ignition Timing .

    Is the inspection result normal?

    YES

    GO TO 14.

    NO

    Follow the Work Procedure .

  14. CHECK A/F SENSOR 1 INPUT SIGNAL CIRCUIT 
    1. Turn ignition switch OFF.
    2. Disconnect corresponding A/F sensor 1 harness connector.
    3. Disconnect ECM harness connector.
    4. Check the continuity between A/F sensor 1 harness connector and ECM harness connector.

      +

      -

      Continuity

      A/F sensor 1

      ECM

      Bank

      Connector

      Terminal

      Connector

      Terminal

      1

      F65

      3

      F77

      66

      Existed

      4

      67

      2

      F5

      3

      76

      4

      77

    5. Check the continuity between A/F sensor 1 harness connector and ground, or ECM harness connector and ground.

      +

      -

      Continuity

      A/F sensor 1

      Bank

      Connector

      Terminal

      1

      F65

      3

      Ground

      Not existed

      4

      2

      F5

      3

      4

      +

      -

      Continuity

      ECM

      Bank

      Connector

      Terminal

      1

      F77

      66

      Ground

      Not existed

      67

      2

      76

      77

    6. Also check harness for short to power.

    Is the inspection result normal?

    YES

    GO TO 15.

    NO

    Repair open circuit, short to ground or short to power in harness or connectors.

  15. CHECK A/F SENSOR 1 HEATER 

    Refer to Component Inspection .

    Is the inspection result normal?

    YES

    GO TO 16.

    NO

    Replace (malfunctioning) A/F sensor 1. Refer to Component Parts Location .

  16. CHECK MASS AIR FLOW SENSOR 

    SYMBOL With CONSULT

    Check mass air flow sensor signal in "DATA MONITOR" mode of "ENGINE" using CONSULT.

    For specification, refer to Mass Air Flow Sensor .

    SYMBOL With GST

    Check mass air flow sensor signal in Service $01 with GST.

    For specification, refer to Mass Air Flow Sensor .

    Is the measurement value within the specification?

    YES

    GO TO 17.

    NO

    Check connectors for rusted terminals or loose connections in the mass air flow sensor circuit or ground. Refer to DTC Diagnosis Procedure .

  17. CHECK SYMPTOM TABLE 

    Check items on the rough idle symptom in Symptom Table .

    Is the inspection result normal?

    YES

    GO TO 18.

    NO

    Repair or replace error-detected parts.

  18. ERASE THE 1ST TRIP DTC 

    Some tests may cause a 1st trip DTC to be set.

    Erase the 1st trip DTC from the ECM memory after performing the tests.

    SYMBOL With CONSULT: Refer to CONSULT Function .

    SYMBOL Without CONSULT: Refer to On Board Diagnosis Function .

    GO TO 19.

  19. CHECK INTERMITTENT INCIDENT 

    Refer to Intermittent Incident .

    INSPECTION END