Driver Side
- CHECK FUSE
Check if any of the following fuses are blown.
Signal name
Fuse No.
Battery power supply
68 (15A)
IGN power supply
29 (5A)
Is the fuse blown?
YES
Replace the blown fuse after repairing the affected circuit.
NO
GO TO 2.
- CHECK CLIMATE CONTROLLED SEAT CONTROL UNIT (DRIVER SIDE) POWER SUPPLY
- Turn ignition switch OFF.
- Disconnect climate controlled seat control unit (driver side) connector.
- Turn ignition switch ON.
- Check voltage between climate controlled seat control unit (driver side) harness connector and ground.
(+)
(-)
Voltage (V)
(Approx.)
Climate controlled seat control unit (driver side)
Connector
Terminal
B205
29
Ground
Battery voltage
Is the inspection result normal?
YES
GO TO 7.
NO
GO TO 3.
- CHECK CLIMATE CONTROLLED SEAT CONTROL UNIT (DRIVER SIDE) POWER SUPPLY CIRCUIT
- Turn ignition switch OFF.
- Disconnect climate controlled seat relay.
- Check continuity between climate controlled seat control unit (driver side) harness connector and climate controlled seat relay harness connector.
Climate controlled seat control unit (driver side)
Climate controlled seat relay
Continuity
Connector
Terminal
Connector
Terminal
B205
29
M58
6
Yes
- Check continuity between climate controlled seat control unit (driver side) harness connector and ground.
Climate controlled seat control unit (driver side)
Ground
Continuity
Connector
Terminal
B205
29
No
Is the inspection result normal?
YES
GO TO 4.
NO
Repair or replace harness or connector.
- CHECK CLIMATE CONTROLLED SEAT RELAY POWER SUPPLY CIRCUIT
- Turn ignition switch ON.
- Check voltage between climate controlled seat relay harness connector and ground.
(+)
(-)
Voltage (V)
(Approx.)
Climate controlled seat relay
Connector
Terminal
M58
2
Ground
Battery voltage
7
Is the inspection result normal?
YES
GO TO 5.
NO
Repair or replace harness or connector.
- CHECK CLIMATE CONTROLLED SEAT RELAY GROUND CIRCUIT
- Turn ignition switch OFF.
- Check continuity between climate controlled seat relay harness connector and ground.
Climate controlled seat relay
Ground
Continuity
Connector
Terminal
M58
1
Yes
Is the inspection result normal?
YES
GO TO 6.
NO
Repair or replace harness.
- CHECK CLIMATE CONTROLLED SEAT RELAY
Check climate controlled seat relay.
Refer to Component Inspection .
Is the inspection result normal?
YES
GO TO 7.
NO
Replace climate controlled seat relay.
- CHECK CLIMATE CONTROLLED SEAT CONTROL UNIT (DRIVER SIDE) GROUND CIRCUIT
- Turn ignition switch OFF.
- Check continuity between climate control unit (driver side) harness connector and ground.
Climate controlled seat control unit (driver side)
Ground
Continuity
Connector
Terminal
B205
27
Yes
Is the inspection result normal?
YES
Check intermittent incident. Refer to Intermittent Incident .
NO
Repair or replace harness or connector.