NVH Troubleshooting Chart
WARNING: This page is about a different variant/trim than selected.
Use the chart below to help you find the cause of the symptom. The numbers indicate the order of the inspection. If necessary, repair or replace these parts.
MANUAL TRANSMISSION - RS6F52A - NOISE SYMPTOM TABLE
| SUSPECTED PARTS (POSSIBLE CAUSE) |
|---|
| 1. OIL (Oil level is low.) |
| 2. OIL (Wrong oil.) |
| 3. GEAR (Worn or damaged) |
| 3. BEARING (Worn or damaged) |
MANUAL TRANSMISSION - RS6F52A - OIL LEAKAGE SYMPTOM TABLE
| SUSPECTED PARTS (POSSIBLE CAUSE) |
|---|
| 3. OIL (Wrong oil.) |
| 1. OIL (Oil level is high.) |
| 2. GASKET (Damaged) |
| 2. OIL SEAL (Worn or damaged) |
MANUAL TRANSMISSION - RS6F52A - HARD TO SHIFT OR WILL NOT SHIFT SYMPTOM TABLE
| SUSPECTED PARTS (POSSIBLE CAUSE) |
|---|
| 1. OIL (Wrong oil.) |
| 1. OIL (Oil level is high.) |
| 2. SHIFT CONTROL LINKAGE (Worn) |
| 3. BAULK RING (Worn or damaged) |
| 3. INSERT SPRING (Damaged) |
MANUAL TRANSMISSION - RS6F52A - JUMPS OUT OF GEAR SYMPTOM TABLE
| SUSPECTED PARTS (POSSIBLE CAUSE) |
|---|
| 1. SHIFT CONTROL LINKAGE (Worn) |
| 2. STRIKING ROD ASSEMBLY (Worn or damaged) |
| 3. SHIFT FORK (Worn) |
| 3. GEAR (Worn or damaged) |