Body Equipment - Repair -- Cooper (F54)
- 51 00 General Body Equipment
- 51 11 Bumper, Front
- Installing/replacing license plate (without number plate baseplate)
- Removing and installing/replacing support for front bumper cover
- Removing and installing/replacing support for front lower bumper cover
- Remove and install/replace the center spoiler on bumper cover
- Remove and install front bumper cover
- Replacing base plate for number/license plate
- Removing and installing/replacing the ornamental grille in the bumper cover
- Removing/installing/replacing center trim
- Remove and install/replace deformation element for front left bumper
- Remove and install/replace deformation element for front right bumper
- Replace the front deformation element on the bottom left
- Replace the front deformation element on the bottom right
- Removing and installing/replacing the air inlet frame for the left or right brake ventilation duct (only Cooper Clubman S and JCW)
- 51 12 Bumper, Rear
- Removing and installing/replacing support for rear bumper panel
- Replace the center spoiler on rear bumper panel
- Removing and installing rear bumper panel
- Replace rear bumper panel
- Removing and installing/replacing guide for bumper, rear left or right
- Removing and installing/replacing side spoiler side on rear bumper panel (only Cooper Clubman S and JCW) *****
- Removing and installing/replacing trim on rear bumper panel (only Cooper Clubman JCW) *****
- Removing and installing/replacing trim on bumper cover rear left or right (only Cooper Clubman JCW) *****
- 51 13 Trim Parts, Covers, Handle Strip
- Removing and installing/replacing front grill center section
- Removing and installing/replacing ornamental grille frame
- Removing and installing/replacing trim ring for left or right headlight
- Removing and installing/replacing trim strip on engine compartment lid (cowl panel)
- Removing and installing/replacing side panel trim strip, left or right
- Removing and installing/replacing trim on front left or right wheel arch
- Removing and installing/replacing trim on rear left or right wheel arch
- Removing and installing/replacing trim (wheel arch) at rear door, left or right
- Removing and installing/replacing the windshield panel cover (front)
- Detaching and attaching/replacing windshield panel cover (rear)
- Removing and installing/replacing left or right roof railing
- Detaching and attaching/replacing window channel strip on left or right split door
- Removing and installing/replacing front compartment lid air duct (only Cooper Clubman JCW) *****
- 51 14 Plates, Labels, Adhesive Films
- 51 16 Mirrors, Decorative Strips, Ashtrays, Consoles
- Removing and installing/replacing the left or right vehicle exterior mirror on the front door
- Replacing mirror glass
- Removing and installing/replacing cover cap on the left or right exterior mirror (production date up to 07/19)
- Removing and installing/replacing protective cap on left or right outside rearview mirror (production date from 07/19 onward)
- Removing and installing/replacing interior rearview mirror (overview)
- Removing and installing/replacing interior rearview mirror
- Removing and installing or replacing sun visor and left or right counter support
- Removing and installing/replacing sun visor and counter support on driver's side (side)
- Removing and installing/replacing center console cover
- Removing and installing/replacing rear center console cover
- Removing and installing/replacing center armrest storage compartment
- Replacing center console support
- Removing and installing/replacing front cup holder
- Removing and installing/replacing center armrest
- Removing and installing/replacing trim on center console at side left or right
- Removing and installing/replacing glove compartment cover
- Removing and installing/replacing right glove compartment with housing
- Remove and install/replace damper for glove compartment
- Removing and installing/replacing rear left/right grab handle
- Removing and installing or replacing front grab handle
- 51 21 Door Locks, Handles, Fittings, Front
- Removing window channel strip with special tool 00 9 324 at front or rear
- Replacing front left or right lock striker
- Adjusting front left or right lock striker
- Removing and installing/replacing the door lock of the driver's door
- Removing and installing/replacing the door lock of the front passenger door
- Removing and installing/replacing support for left or right outer door handle with lock cylinder
- Removing and installing/replacing support for left or right outer door handle without lock cylinder
- Removing and installing/replacing complete lock cylinder in left or right front door
- Removing and installing/replacing the outside door handle on the left or right front door
- Removing and installing or replacing inside door opener in left or right front door
- Removing and installing/replacing Bowden cable for outer door handle on left or right front door
- Remove and install/replace Bowden cable for inner door opener on left or right front door
- Remove and install/replace door stop of the front left or front right door
- Removing and installing/replacing the window channel strip on the outside of the front door
- Removing and installing/replacing window channel strip on inner front door
- Removing and installing/replacing cover at bottom left or right on front door
- 51 22 Door Locks, Handles, Fittings, Rear
- Replacing door detent (lock striker), rear left or right
- Adjusting rear left or right door lock striker
- Removing and installing/replacing the door lock in the left or right rear door
- Removing and installing/replacing support for outer door handle in left or right rear door
- Removing and installing/replacing the outside door handle on the left or right rear door
- Removing and installing/replacing inside door opener of rear left or right door
- Removing and installing/replacing Bowden cable for outer door handle in left or right rear door
- Removing and installing/replacing Bowden cable for inside door opener on left or right rear door
- Removing and installing/replacing the door check on the left or right rear door
- Removing and installing/replacing window channel strip on outside of rear door
- Removing and installing/replacing the window channel strip on the inside of the rear door
- Removing and installing/replacing cover (gasket) on rear door at bottom left or right
- 51 23 Hood Latch, Locks
- Adjusting/replacing bump stops
- Removing/installing ball sockets with clip
- Adjusting engine compartment lid catch
- Removing and installing/replacing right engine compartment lid lock
- Removing and installing/replacing left engine compartment lid lock
- Removing and installing/replacing striker on engine compartment lid
- Removing and installing/replacing cable for front engine compartment locks (in engine compartment)
- Removing and installing/replacing cable for engine compartment lock, front (in passenger compartment)
- Removing and installing/replacing left or right gas spring for engine compartment lid
- 51 24 Tailgate Latch, Locks
- Detaching and attaching/replacing door handle on left split door
- Removing and installing/replacing door handle on split door]
- Removing and installing/replacing tailgate lock for left split door
- Removing and installing/replacing tailgate lock for right split door
- Replace striker for left split door
- Replace striker for right split door
- Replacing gas spring for left split door
- Replace gas spring for right split door
- 51 31 Front And Rear Window
- General procedure for the disassembly and installation of bonded window glass
- Materials for bonding window
- Notes on window bonding repair kit
- Remove windshield with "Roll Out 2000"
- Removing windows with an oscillating knife
- Removing windows with a "Spider"
- Window glass removal with wire pull handle
- Replace windshield
- Removing and installing/replacing windshield rubber frame
- Removing and installing/replacing trim for left or right A-pillar
- Replace the rear window on the left (or right) split door
- 51 32 Window Systems With Manual Actuation, Front
- 51 33 Window Systems With ELEC. Actuation, Front
- 51 34 Window Systems With Manual Actuation, Rear
- 51 36 Side Window, Body, Manually Operated
- 51 37 Side Window, Body, ELEC. Actuation
- 51 41 Front Door Trim Panel With Armrests
- 51 42 Rear Door Trim Panel With Armrests
- 51 43 Side Trim Panel With Armrests
- Removing and installing/replacing side trim panel, footwell, on A-pillar, left
- Removing and installing/replacing side trim panel, footwell, on A-pillar, right
- Remove and install/replace trim panel for B-pillars (above) left or right
- Removing and installing or replacing trim for left or right door pillar (bottom)
- Removing and installing or replacing trim for roof pillar at front (A-pillar), left or right
- Removing and installing or replacing trim panel for left or right rear roof pillar (C-pillar)
- Remove and install/replace left D-pillar trim panel
- Remove and install/replace right D-pillar trim panel
- 51 44 Roof Trim Panel
- 51 45 Trim Panel, Instrument Panel
- Removing and installing/replacing side panel on dashboard on left or right
- Removing and installing instrument panel trim
- Replacing the dashboard trim
- Removing and installing/replacing carrier for dashboard
- Removing and installing (replacing) lower left instrument panel trim
- Removing and installing/replacing instrument panel trim, bottom right
- Removing and installing (replacing) left decorative strip on dashboard
- Removing and installing (replacing) right decorative strip on dashboard
- Removing and installing (replacing) middle decorative strip on dashboard
- Removing and installing/replacing cover for instruments
- 51 46 Rear Deck Trim Panel, Roller SUNBLIND
- 51 47 Floor-Trunk-Engine Compartment-Trim Panel
- Removing and installing/replacing front left or right door sill cover strip
- Remove and install/replace (inner) door sill cover strip, rear left or right
- Removing and installing/replacing luggage compartment floor covering
- Removing and installing/replacing roller cover for luggage compartment
- Removing and installing/replacing left trunk wheel arch trim
- Removing and installing/replacing cover for left or right luggage compartment
- Removing and installing/replacing right trunk wheel arch panel
- Removing and installing/replacing carpet for vehicle interior
- Removing and installing or replacing rear carpet on seat pan
- Removing and installing/replacing underbody protection (front)
- Removing refitting/replacing rear engine undercover
- 51 48 Damping Layer, Hood
- 51 49 Tailgate Trim Panel
- Removing and installing/replacing left trim panel for split door
- Detaching and attaching/replacing trim panel for right split door
- Detaching and attaching/replacing trim panel for rear window frame at left split door
- Detaching and attaching/replacing trim panel for rear window frame at right split door
- 51 71 Gaskets And Loose Body Parts
- Remove and install/replace left or right lower front brake air duct
- Removing and installing/replacing front left or right wheel arch cover
- Removing and installing/replacing front left or right wheel arch cover (front and rear section)
- Removing and installing/replacing the rear left or right wheel arch cover
- Removing and installing/replacing upper Firewall cover
- Removing and installing/replacing the automatic air flap control
- Removing and installing/replacing rear spoiler
- Detaching and attaching/replacing rear spoiler lower part
- Replacing cover on trim panel for cover on side member, left or right
- Detaching and attaching/replacing trim panel for left or right door sill
- Removing and installing/replacing left or right tension strut
- 51 72 Edge Protection For Doors
- 51 75 UNDERSHIELD
- 51 76 Seals