LEMON Manuals: Even more car manuals for everyone
Home >> Mini >> 2015 >> Cooper Countryman Base, 1.6L Eng, Standard Trans >> Repair and Diagnosis >> External Pages >> Different car >> Section 34 (Heating And Air Conditioning - Repair (R61) -- Cooper Paceman) >> Air Conditioning Leak Detection >> 64 50 010 Drawing off, evacuating and filling heating and air conditioning system (R134a) >> Instructions for drawing off heating and air conditioning system

Instructions for drawing off heating and air conditioning system

WARNING: This page is about a different car, the 2016 MINI Cooper Paceman, 2015 MINI Cooper Paceman, 2014 MINI Cooper Paceman, and 2013 MINI Cooper. However, it is still accessible from the selected car via links, so may be relevant.

To help separation of refrigerant and refrigerant oil, run engine at low speed (800-1200 RPM) and with heating and air conditioning system turned on for a few minutes.

The limits the entrainment of refrigerant oil while it is drawn off.

Drawn-off refrigerant oil must be changed and reintroduced via the service station.

During drawing off, set blower of heating and air-conditioning unit to middle blower speed. This ensures that drawing off is more effective since the pressure on the low pressure side increases.

Recycling:

Dispose of drawn-off refrigerant oil as hazardous waste.

Observe country-specific waste disposal regulations.

IMPORTANT: Vehicle must be evacuated from both sides.
scientia non olet · About LEMON Manuals