Body Equipment - Repair (R60) -- Cooper Countryman
- Safety And General Information
- 00 Safety information for working on vehicles with automatic engine start-stop function (MSA)
- 51 00... Safety information for working on vehicles with airbag systems
- 51 00... Notes on component bonding with adhesive tape
- 51 00... Notes on installing rubber window seals
- 51 00.. Overview of front door
- 51 00.. Overview of rear door
- 41 00... Replacing bolts
- 41 00... Replacing blind rivets
- 51 00... Overview of consumables
- Front Bumper
- 51 11... Overview of front bumper
- 51 11 152 Remove and installing/replacing the center spoiler on bumper panel
- 51 11 156 Removing and installing front bumper panel
- 51 11 180 Removing and installing/replacing ornamental grille in bumper panel
- 51 11 182 Removing and installing/replacing ornamental grille in bumper panel at top front
- 51 11 050 Removing and installing/replacing support for front bumper panel
- 51 11 157 Replacing bumper panel, front
- Rear Bumper
- 51 12... Overview of rear bumper
- 51 12 156 Removing and installing rear bumper panel
- 51 12 825 Removing and installing/replacing guide for rear center bumper
- 51 12 100 Removing and installing/replacing rear number plate support
- 51 12 050 Removing and installing/replacing support for rear bumper panel
- 51 12 070 Replacing the center spoiler on rear bumper panel
- 51 12 801 Replacing holder for rear bumper at left or right
- 51 12 157 Replacing rear bumper panel
- Trim, Covers, Handle Trim
- 51 13 305 Removing and installing/replacing left or right roof railing
- 51 13 106 Removing and installing/replacing cover (wheel arch) at rear door, left or right
- 51 13 102 Removing and installing/replacing cover on front left or right wheel arch
- 51 13 095 Removing and installing/replacing cover on front side wall left or right
- 51 13 375 Removing and installing/replacing cover on left or right rear roof pillar (D-pillar)
- 51 13 105 Removing and installing/replacing cover on wheel arch
- 51 13 000 Removing and installing/replacing front grille center section
- 51 13 091 Removing and installing/replacing front side panel trim strip, left or right
- 51 13 123 Removing and installing/replacing left cowl panel cover
- 51 13 301 Removing and installing/replacing left or right roof strip
- 51 13 124 Removing and installing/replacing right cowl panel cover
- 51 13... Removing and installing/replacing seal on rear door (in area of wheel arch), left or right
- 51 13 015 Removing and installing/replacing trim ring for left or right headlight
- 51 13 085 Removing and installing/replacing trim strip on engine hood/bonnet (cowl panel)
- Mini Emblems, Model Emblems
- 51 14... General notes for labelling with adhesive films
- 51 14... Instructions for attaching number/letter designation combination
- 51 14 002 Removing and installing/replacing front MINI badge
- 51 14 012 Removing and installing/replacing rear MINI plate
- 51 14 006 Replacing badge emblem on left or right front door
- 51 14 110 Removing and installing/replacing rear model designation
- Mirrors/Covers/Ashtrays/Shelves/Trays
- 51 16... Overview of center console
- 51 45.. Overview of dashboard
- 51 16... Calibrating the compass on the inside mirror
- 51 16 480 Removing and installing or replacing front grab handle
- 51 16 060 Removing and installing or replacing inside mirror
- 51 16 000 Removing and installing or replacing mirror on left or right front door
- 51 16 080 Removing and installing or replacing sun visor and left or right counter support
- 51 16 366 Removing and installing right glove box with housing
- 51 16... Removing and installing the lid on the rear center console cover
- 51 16 206 Removing and installing/replacing center armrest
- 51 16 160 Removing and installing/replacing center console cover
- 51 16 165 Removing and installing/replacing complete center console
- 51 16... Removing and installing/replacing decorative ring on gearshift lever cover
- 51 16 202 Removing and installing/replacing front cupholder
- 51 16 365 Removing and installing/replacing glove box cover
- 51 16... Removing and installing/replacing holder for inside mirror
- 51 16 041 Removing and installing/replacing protective cap on left or right exterior mirror
- 51 16 274 Removing and installing/replacing rear center console
- 51 16 450 Removing and installing/replacing rear left/right grab handle
- 51 16 200 Removing and installing/replacing storage compartment
- 51 16 254 Removing and installing/replacing the rail (long)
- 51 16 026 Replacing mirror glass
- Front Door Locks, Handles, Fittings
- 51 00.. Overview of front door
- 51 21 004 Adjusting front left or right lock striker
- 51 21 225 Removing and installing or replacing inside door opener in left or right front door
- 51 21 170 Removing and installing or replacing outer door handle from left or right front door
- 51 21 300 Removing and installing or replacing window cavity cover strip on outside of left or right front door
- 51 21 330 Removing and installing/renewing weather strip on inner front door
- 51 21 235 Removing and installing/replacing Bowden cable for inside door opener on left or right front door
- 51 21 090 Removing and installing/replacing door lock in left or right front door
- 51 21 280 Removing and installing/replacing door stop on left or right front door
- 51 21 130 Removing and installing/replacing left or right front door lock
- 51 21... Removing weather strip with special tool 00 9 324 at front or rear
- 51 21 003 Replacing door detent (lock striker), front left or right
- Rear Door Locks, Handles, Fittings
- 51 00.. Overview of rear door
- 51 22 004 Adjusting rear left or right door lock striker
- 51 22 235 Removing and installing/replacing Bowden cable for inside door opener on left or right rear door
- 51 22 090 Removing and installing/replacing door lock in left or right rear door
- 51 22 280 Removing and installing/replacing door stop on left or right rear door
- 51 22 225 Removing and installing/replacing inside door opener of rear left or right door
- 51 22 170 Removing and installing/replacing outer door handle on left or right rear door
- 51 22 330 Removing and installing/replacing weather strip on inside rear door
- 51 22 300 Removing and installing/replacing weather strip on outside of rear door
- 51 22 001 Replacing door detent (lock striker), rear left or right
- Hood Latch, Locks
- 51 23 004 Adjusting engine compartment lid catch
- 51 23... Adjusting/replacing bump stops
- 51 23 200 Remove, installing/replacing lever with console for engine compartment lid catch
- 51 23 160 Removing and installing/replacing arrester hook on engine hood
- 51 23 212 Removing and installing/replacing cable for front engine hood/bonnet locks (in passenger compartment)
- 51 23 215 Removing and installing/replacing cable for front hood/bonnet locks (in engine compartment) on right and left
- 51 23 110 Removing and installing/replacing left engine compartment lid lock
- 51 23 265 Removing and installing/replacing left or right gas pressure spring for engine compartment lid
- 51 23 100 Removing and installing/replacing right engine compartment lid lock
- Trunk Latch, Locks
- 51 24 004 Adjusting tailgate lock
- 51 24 300 Removing and installing or replacing left or right gas pressure spring for tailgate
- 51 24 146 Removing and installing/replacing button for rear lid actuation
- 51 24 130 Removing and installing/replacing striker for tailgate lock
- 51 24 100 Removing and installing/replacing tailgate lock
- Front And Rear Window
- 61 35... Overview, rain sensor (additional work when replacing the windscreen/sensor replacement)
- 51 31... General procedure for the disassembly and installation of bonded window glass
- 51 31... Materials for bonding window
- 51 31... Notes on window bonding repair kit
- 51 31... Remove windscreen with "Roll Out 2000"
- 51 31 000 Removing and installing/renewing windscreen
- 51 31 284 Removing and installing/replacing lower cover on rear window
- 51 31 200 Removing and installing/replacing rear window
- 51 31 045 Removing and installing/replacing trim cover on A-pillar (outer), left or right
- 51 31... Removing windows with a "Spider"
- 51 31... Removing windows with an oscillating knife
- 51 31 015 Repairing damage to windscreens caused by pitting (stone chips) (clear and tinted laminated safety glass)
- 51 31... Window glass removal with wire pull handle
- Front Manually Operated Windows
- Front Windows
- 51 33 000 Removing and installing (replacing) power window regulator in left or right front door
- 51 32 420 Removing and installing/replacing cover on window frame (B-pillar) of front door, left or right
- 51 32 170 Removing and installing/replacing door window glass, front left or right
- 51 32 211 Replacing front left or right rubber guide for left or right door window
- Rear Windows
- Hinged Window
- Power Window Regulator
- Front Door Trim Panel With Arm Rest
- 51 00.. Overview of front door
- 51 48... Notes for bonding sound insulation (SI), doors
- 51 41 110 Remove and installing/replacing the door handle recess
- 51 41 000 Removing and installing front left or right door trim panel (from 11/2012)
- 51 41 000 Removing and installing front left or right door trim panel (up to 11/2012)
- 51 41 017 Removing and installing/replacing cover on door handle (inside), front left or right
- 51 41... Removing and installing/replacing front (inside) left or right door opener cover
- 51 48 060 Removing and installing/replacing sound insulation in left or right front door
- 51 41 001 Replacing left or right front door trim panel
- Rear Door Trim Panel With Arm Rest
- 51 00.. Overview of rear door
- 51 48... Notes for bonding sound insulation (SI), doors
- 51 42 000 Remove and install left or right rear door trim panel
- 51 42 060 Removing and installing/replacing armrest in rear door, left or right
- 51 42 017 Removing and installing/replacing cover on door handle (inside), rear left or right
- 51 48 070 Removing and installing/replacing sound insulation on left or right rear door
- 51 42 001 Replacing left or right rear door trim panel
- Side Covering With Armrests
- 51 43 150 Removing and installing or replacing trim panel for left or right door post (lower)
- 51 43 251 Removing and installing or replacing trim panel for left or right rear roof pillar (C-pillar)
- 51 43 201 Removing and installing or replacing trim panel for roof pillar at front (A-pillar), left or right
- 51 43 148 Removing and installing or replacing trim panel on left or right door post (upper)
- 51 43 259 Removing and installing/replacing trim panel for rear roof pillar (D-pillar), left or right
- Roof Trim Panel
- 51 44 002 Removing and installing (replacing) headlining (on version without panorama glass roof)
- 51 44 152 Removing and installing/replacing front roofliner cover
- 51 44 013 Removing and installing/replacing headlining (version with panorama glass roof)
- 51 44 156 Removing and installing/replacing rear roofliner cover
- Instrument Cluster Trim Panel
- 51 45.. Overview of dashboard
- 51 45 180 Removing and installing (replacing) instrument panel trim, bottom left
- 51 45 072 Removing and installing dashboard completely with support
- 51 45 050 Removing and installing dashboard upper section trim
- 51 45 430 Removing and installing/replacing air outlet vent cover on left side
- 51 45 432 Removing and installing/replacing air outlet vent cover on right side
- 72 12 006 Removing and installing/replacing airbag module for passenger knee protection
- 51 45... Removing and installing/replacing bottom left dashboard trim panel
- 51 45 435 Removing and installing/replacing cover for instruments
- 51 45 181 Removing and installing/replacing for lower instrument panel trim (only US incl. knee airbag)
- 51 45 181 Removing and installing/replacing lower right instrument panel trim
- 51 45... Removing and installing/replacing lid of air outlet vent cover, left or right
- 51 45 076 Replacing carrier for dashboard
- 51 45 321 Replacing decorative trim on dashboard -driver's side-on left
- 51 45 323 Replacing decorative trim on dashboard -driver's side-on right
- 51 45 265 Replacing instrument panel trim panel
- 51 45 331 Replacing right decorative trim on dashboard
- 51 45 051 Replacing upper part of dashboard trim panel
- Parcel Shelf Trim Panel/Roller Sun Blind
- Floor/Luggage Compartment/Engine Compartment Trim Panels
- 51 47 490 Removing and installing/replacing front underbody protection
- 51 47 314 Removing and installing/replacing carpet for passenger compartment
- 51 47 065 Removing and installing/replacing cover at front left or right entrance
- 51 47 072 Removing and installing/replacing finishing strip at rear left or right entrance
- 51 47 490 Removing and installing/replacing front assembly underbody protection (diesel)
- 51 47 000 Removing and installing/replacing front left or right door sill cover strip
- 51 47 151 Removing and installing/replacing left luggage compartment wheel arch panel
- 51 75 001 Removing and installing/replacing left or right underbody cover
- 51 47 101 Removing and installing/replacing luggage compartment floor trim panel
- 51 47 030 Removing and installing/replacing rear left door sill cover strip
- 51 47 161 Removing and installing/replacing right luggage compartment wheel arch panel
- Front Lid Insulation Lining
- Rear Lid Trim Panel
- Gaskets/Seals, Loose Body Components
- 51 71 040 Removing and installing/replacing front left or right wheel arch cover
- 51 71... Removing and installing/replacing heater end panel
- 51 71 041 Removing and installing/replacing rear left or right wheel arch cover
- 51 71 412 Removing and installing/replacing rear spoiler
- 51 71 447 Removing and installing/replacing trim panel for cover on frame side member (left or right)
- MUCKET For Doors