41 14 021 Stripping Operations - Replacing Front Left Wheel Arch
WARNING: This page does not describe the selected car, but rather 21 other vehicles, including the 2017 BMW 550i GT xDrive, 2017 BMW 535i GT xDrive, 2017 BMW 535i GT, 2016 BMW 550i GT xDrive, and 2016 BMW 535i GT xDrive. However, it is still accessible from the selected car via links, so may be relevant.
NOTE:
Owing to the different engine variants and equipment specifications, not all the components are taken into consideration.
The following list basically represents the removal sequence.
The following list basically represents the removal sequence.
- Disconnect negative battery cable (FR number: 61 20 900)
- Remove bumper trim (job number: 51 11 156
- Remove bumper support (job number: 51 11 050)
- Remove headlight (job number: 63 12 010)
- Remove radiator (job number: 17 11 000)
- Remove A/C system condenser (job number: 64 53 550)
- Remove and install charge air cooler (job number: 17 51 000)
- Remove hydraulic steering cooling coil (job number: 17 11 370)
- Remove intake silencer housing (job number: 41 35 111)
- Remove coolant expansion tank (job number: 17 11 100)
- Remove wheel arch cover (front section) (job number: 51 71 038)
- Remove wheel arch cover (rear section) (job number: 51 71 039)
- Front axle complete with engine and transmission (job number: 31 10 001)
- Engine compartment lid seal locator (job number 51 76 035).
- Remove engine compartment lid (job number 41 61 000)
- Remove engine compartment lid hinge (job number: 41 61 050)
- Remove left side wall (job number: 41 35 050)
- Remove top left wishbone (job number: 31 12 002)
- Remove left suspension brace (job number: 51 71 345)
- Remove bulkhead sound insulation
- Remove brake booster (job number: 34 33 000)
- Remove/detach hydraulic lines for power steering pump.
- Detach coolant hoses
- Detach fuel lines
- Release left wiring harness
- Partially release/remove thermal protection