31 11 001 Replacing Front Axle Carrier
Secure engine in installation position to prevent it from falling down. See 11 00 670 SECURING ENGINE IN INSTALLATION POSITION (N62, N62TU) .
Adhere to the utmost cleanliness. Do not allow any dirt to enter the hydraulic system.
Seal off hydraulic lines with plugs.
Necessary preliminary tasks:
- Secure engine in installation position . See 11 00 670 SECURING ENGINE IN INSTALLATION POSITION (N62, N62TU) .
- Disconnect battery negative lead . See 61 20 900 DISCONNECTING AND CONNECTING BATTERY NEGATIVE LEAD .
- Draw off and dispose off hydraulic fluid from fluid reservoir
- Remove front wheels
- Remove stabilizer . See 31 35 000 REMOVING AND INSTALLING/REPLACING FRONT STABILIZER .
- If necessary, remove rear assembly underside protection . See 51 47 491 REMOVING AND INSTALLING/REPLACING REAR UNDERBODY PROTECTION .
- Remove air duct for brake ventilation on both sides
- Remove reinforcement plate . See 31 10 010 REMOVING AND INSTALLING/REPLACING REINFORCEMENT PLATE .
- If necessary, remove steering gear cover on both sides
- Remove universal joint from power steering gear . See 32 31 211 REPLACING UNIVERSAL JOINT FOR LOWER SECTION OF STEERING SPINDLE .
- Disconnect plug connection on Servotronic converter
- Disconnect plug connection from ride-height sensor
- If necessary, disconnect vacuum line from electrically operated valve to engine mounts at T-piece
- Remove pressure line and if necessary Dynamic Drive pressure line from vane pump . See 32 41 037 REMOVING AND INSTALLING POWER STEERING PUMP (N62, N62TU) FOR POWER STEERING GEAR WITH DYNAMIC DRIVE (FROM 10/2003) or 32 41 060 REMOVING AND INSTALLING VANE PUMP (N62, N62TU) FOR POWER STEERING (FROM 10/2003) .
- Disconnect return line from power steering cooler . See 32 41 ... NOTES ON HYDRAULIC LINE WITH QUICK-CONNECT COUPLING .
- Remove tension strut on both sides from front axle carrier . See 31 12 080 REMOVING AND INSTALLING/REPLACING BOTH TENSION STRUTS .
- Remove control arm on both sides from front axle carrier . See 31 12 000 REMOVING AND INSTALLING/REPLACING LEFT OR RIGHT CONTROL ARM .
- Remove tie rod end on both sides from swivel bearing . See 32 21 151 REPLACING LEFT OR RIGHT TIE ROD .
Lower front axle carrier . See 31 11 001 REPLACING FRONT AXLE CARRIER .
Version with Dynamic Drive:
- Remove pressure lines for oscillating motor of front axle with hose/pipe holders. See 37 13 100 REMOVING AND INSTALLING/REPLACING PRESSURE LINES FOR OSCILLATING MOTOR/FRONT AXLE .
- Remove vent hose with filter . See 37 10 005 REMOVING AND INSTALLING/REPLACING VENT HOSE (FROM 06/2003) FOR ACTIVE STABILIZER (FRONT) .
Remove heat shield(s).
Disconnect hydraulic lines from power steering gear and front axle carrier. See 32 13 060 REMOVING AND INSTALLING/REPLACING POWER STEERING GEAR .
Remove engine mount/mounting bracket on both sides and if necessary remove with vacuum lines from front axle carrier. See 22 11 001 REPLACING RIGHT ENGINE MOUNT (N62/N62TU) and 22 11 011 REPLACING LEFT ENGINE MOUNT (N62/N62TU) .
Remove power steering gear . See 32 13 060 REMOVING AND INSTALLING/REPLACING POWER STEERING GEAR .
E65, 66: Remove vehicle jack support.
Take front axle carrier down and set down on a suitable surface.
Installation:
Use previous front axle carrier as a template for modifying or replacing small parts.
After installation:
- Fill and bleed hydraulic system . See 32 13 006 BLEEDING POWER STEERING (VERSION WITH DYNAMIC DRIVE) or 32 13 006 BLEEDING POWER STEERING UNIT .
- Check pipe connections for leaks
- Perform chassis alignment check . See 32 00 ... CHASSIS/WHEEL ALIGNMENT CHECK PROCEDURE .
- Carry out steering angle sensor adjustment . See 61 31 996 CARRY OUT STEERING ANGLE SENSOR ADJUSTMENT .
- If necessary, carry out initial Dynamic Drive operation . See 37 10 001 INITIAL OPERATION WITH TEST RUN OF DYNAMIC DRIVE .