LEMON Manuals: Even more car manuals for everyone
Home >> Mini >> 2010 >> Cooper S, 2D Hatchback, Standard >> Repair and Diagnosis >> External Pages >> Different car >> Section 3674 (Automatic Transmission - Repair) >> Extension Housing, Bearings, Seal >> 28 00 060 Replacing Output Flange Shaft Seal (GS7D36SG)

28 00 060 Replacing Output Flange Shaft Seal (GS7D36SG)

WARNING: This page does not describe the selected car, but rather 50 other vehicles, including the 2016 BMW M5, 2016 BMW ActiveHybrid 5, 2016 BMW 550i xDrive, 2016 BMW 550i, and 2016 BMW 535i xDrive. However, it is still accessible from the selected car via links, so may be relevant.

Special tools required: 

IMPORTANT: It is essential to adhere to conditions of absolute cleanliness.
Any dirty parts must be cleaned before the hydraulic cap is loosened.
After completion of repair work, check TRANSMISSION OIL LEVEL .
Use only the approved transmission oil .
Failure to comply with this instruction will result in serious damage to the twin-clutch gearbox.

Necessary preliminary tasks: 

Release screws.

Tightening torque: 22 32 1AZ .

Remove transmission bearing block (1).

Fig 1: Transmission Bearing Block And Screws
G09922326Courtesy of BMW OF NORTH AMERICA, INC.

Grip output flange (1) with special tool 23 0 020 .

Release nut with special tool 23 2 320 .

Tightening torque:

Collar nut installed with screw locking:

Pretension: 175 Nm

Release

Tighten down: 125 Nm

Installation note: 

Replace nut and secure with Loctite 243.

Fig 2: Releasing Output Flange Nut Using Special Tool (23 2 320)
G06905111Courtesy of BMW OF NORTH AMERICA, INC.

Detach output flange (1) with special tool 33 1 150 and adapter plate 33 1 154 from output shaft.

Fig 3: Detaching Output Flange
G04742232Courtesy of BMW OF NORTH AMERICA, INC.

Attach special tool 24 2 353 to output shaft (1).

Graphic shows: Automatic transmission

Fig 4: Attaching Special Tool (24 2 353) To Output Shaft
G04726119Courtesy of BMW OF NORTH AMERICA, INC.

Screw in special tool 24 2 351 until it is firmly connected with radial shaft seal.

Pull out radial shaft seal by screwing in special tool 24 2 352 .

Graphic shows: Automatic transmission

Fig 5: Pulling Radial Shaft Seal
G04726120Courtesy of BMW OF NORTH AMERICA, INC.

Oil sealing lip on radial shaft seal (1). Drive in radial shaft seal (1) with special tool 23 0 410 as far as it will go.

Graphic shows: Automatic transmission

Fig 6: Installing Radial Shaft Seal Using Special Tool (23 0 410)
G06905115Courtesy of BMW OF NORTH AMERICA, INC.