67 61 007 Replacing electric motor with gearbox (rear) to operate the slide/tilt sunroof
WARNING: This page does not describe the selected car, but rather 21 other vehicles, including the 2017 BMW 550i GT xDrive, 2017 BMW 535i GT xDrive, 2017 BMW 535i GT, 2016 BMW 550i GT xDrive, and 2016 BMW 535i GT xDrive. However, it is still accessible from the selected car via links, so may be relevant.
Necessary preliminary work:
- Remove REAR GRAB HANDLES .
- Remove TRIM PANEL FOR REAR LEFT AND RIGHT ROOF PILLAR (C-PILLAR) .
- Remove TRIM PANEL FOR REAR LEFT AND RIGHT ROOF PILLAR (D-PILLAR) .
- Remove COMPLETE INTERIOR ROOF LIGHT .
- Detach edge protection in area of headliner.
IMPORTANT:
Do not under any circumstance kink headliner (1).
Unclip headliner (1) at retaining point (2) towards bottom and lower.
NOTE:
Secure electric motor drive with gearbox (4) from falling out.
Release screws (3).
Tightening torque 54 13 1AZ .
NOTE:
Screws (3) are microencapsulated and must be replaced.
Remove electric motor with gearbox (4).
Unlock plug connection (5) and disconnect.
Installation note:
Insert gear wheel (1) of electric motor with gearbox (2) exactly in gearing (3).
Installation note:
- Initialize SLIDE/TILT SUNROOF .