24 00 034 Removing and installing automatic transmission (GA8HP70Z) (N63)
Special tools required:
To prevent heavy damage to the engine block, the protruding thread of the transmission bolts absolutely must be checked for damage and corrosion before removal .
If there are signs of corrosion, the rust must be removed and the threads must be cleaned before removal .
Replace rusted, damaged screws.
Failure to comply with this instruction will result in serious damage to the engine block and transmission.
- Do not let skin come in contact with transmission oil and do not inhale transmission oil vapors.
- Wear protective gloves.
- Ensure adequate ventilation.
After completion of repair work, check TRANSMISSION OIL LEVEL .
Use only the approved TRANSMISSION OIL .
Failure to comply with this requirement will result in serious damage to the automatic transmission!
Necessary preliminary tasks:
- Clamp off BATTERY .
- Remove BOTH INTAKE SILENCER HOUSINGS .
- Remove underbody protection at front and rear. See REMOVING FRONT UNDERBODY PROTECTION and REMOVING REAR UNDERBODY PROTECTION .
- Remove PROPELLER SHAFT from transmission.
- Release center mountNOTE: Bending the propeller shaft by an excessive angle can cause premature damage to the joint/propeller shaft!
- Tie back propeller shaft to underbody
- Support engine with jack when removing gearbox.
Release screws (1).
Remove cover (2).
Tightening torque 24 00 1AZ .
When unflanging the gearbox, pay attention to installation position of rubber connectors (1).
Release screw (1) and remove crankshaft sensor.
Disengage cable from holder (2).
Release screw (1).
Undo hydraulic line and holder.
Release screw (1).
Disconnect hydraulic lines (2) to transmission oil cooler.
Installation note:
Replace sealing rings.
Keep to installation sequence.
Crank engine at vibration damper in direction of rotation until screw (1) is visible in recess.
Undo all 6 bolts on torque converter.
Tightening torque 24 40 1AZ .
Prepare special tool (1) 24 4 161 (A) with shaped element (2) 24 4 166 as illustrated.
Insert special tool 24 4 160 into recess of transmission housing and clamp gently with screw (1).
Raise by turning screw (2) and clamp down.
Then tighten down screw (1).
Screw on special tool 11 8 910 .
Tightening torque 31 10 1AZ .
Adjust distance (1) between cross bar and facing using nuts (2).
Nuts (2) must be screwed down in opposite direction after distance has been adjusted.
Distance:
N63 38 mm
Supporting transmission:
Support transmission with special tools 23 4 050 , 00 2 030 .
Secure transmission to mounting with tensioning strap (1).
Repair work is are described in GEARBOX HOLDER .
After completion of work, check TRANSMISSION OIL LEVEL .
Unlock and disconnect connector (1) by turning.
Do not touch pins.
Release cable from brackets.
Insert special tool 24 2 390 in sealing cup.
Operations are described in: NOTES ON MECHATRONICS
Lower engine with transmission.
Secure engine and transmission in lowered position with engine support beam.
Then support transmission.
Release screws.
Tightening torque 24 00 1AZ .
Unflange transmission.
Installation note:
Bore (1) in drive plate must be accessible from opening in transmission housing. Check that fitting sleeves (2) are correctly fitted.
Replace damaged fitting sleeves.
Installation note:
Rotate torque converter until bore hole in torque converter is flush with bore hole in drive plate.
Flange automatic transmission to engine.