LEMON Manuals: Even more car manuals for everyone
Home >> Mini >> 2010 >> Cooper S, 2D Hatchback, Standard >> Repair and Diagnosis >> External Pages >> Different car >> Section 1163 (Exhaust System - Repair - E92/E93) >> Mufflers >> 18 10 031 Replacing rear muffler (N52, N52K)

18 10 031 Replacing rear muffler (N52, N52K)

WARNING: This page does not describe the selected car, but rather 14 other vehicles, including the 2013 BMW 328xi, 2013 BMW 328i, 2012 BMW 328xi, 2012 BMW 328i, and 2011 BMW 328xi. However, it is still accessible from the selected car via links, so may be relevant.
WARNING: Scalding hazard!

Only perform these tasks on an engine that has cooled down.

Support rear muffler with special tool 31 2 220 .

Fig 1: Supporting Exhaust System Using Special Tool (31 2 220)
G04742070Courtesy of BMW OF NORTH AMERICA, INC.
NOTE: If the cutting line is not marked by a punch mark in the pipe, determine the cutting line by means of the pipe length on the new rear muffler (2).
Carry over cutting line to faulty rear muffler (2) and mark out.
Fig 2: Identifying Rear Muffler
G06901320Courtesy of BMW OF NORTH AMERICA, INC.

Cut exhaust pipe at marked point with special tool 00 2 210 and deburr.

Fig 3: Identifying Special Tool (00 2 210)
G04742078Courtesy of BMW OF NORTH AMERICA, INC.

Unfasten nut.

Tightening torque 18 20 4AZ .

Fig 4: Locating Nut
G05758984Courtesy of BMW OF NORTH AMERICA, INC.

Release screw on right bracket.

Tightening torque 18 20 5AZ .

Fig 5: Locating Screw
G05476212Courtesy of BMW OF NORTH AMERICA, INC.

Installation: 

Connect front muffler to rear muffler by means of clamp and align.

Centre clamp and tighten down.

Tightening torque 18 20 8AZ .

Fig 6: Identifying Centre Clamp
G04742097Courtesy of BMW OF NORTH AMERICA, INC.
NOTE: Check exhaust system for leaks.
scientia non olet · About LEMON Manuals