LEMON Manuals: Even more car manuals for everyone
Home >> Mercury >> 1982 >> LN7 Standard Trans >> Repair and Diagnosis (Single Page) >> General Information >> Engine Performance >> EPA Emission Recalls - Domestic Cars >> Domestic Cars Emission Recalls

Domestic Cars Emission Recalls

NOTE: In this article, you will find a listing of emission related recalls issued by the EPA, CARB, NHTSA or the manufacturer. Always check for emission recalls when performing a smog check. Ensure underhood emission recall label indicates that recall was performed. Contact your local dealer for recall repair information.
DOMESTIC CARS EMISSION RECALLS

Application Problem Recall No.
1977 
BUICK 
Vehicles with 3.8L (VIN C or N):
Century
LeSabre
Regal
Skyhawk
Skylark		 Federal, EGR Valve Plugging, Excessive NOx Emissions 77-C-13
OLDSMOBILE 
Vehicles with 3.8L (VIN C Or N):
Cutlass
Delta
Omega
Starfire		 Federal, EGR Valve Plugging, Excessive NOx Emissions 77-E-3
PONTIAC 
Vehicles with 3.8L (VIN C Or N):
Bonneville
Catalina
Firebird
LeMans
Sunbird
Ventura		 Federal, EGR Valve Plugging, Excessive NOx Emissions 77-C-20
1978 
BUICK 
Vehicles with 3.8L (VIN A Or 3):
Century
LeSabre
Regal
Skyhawk
Skylark		 EGR Valve Plugging, Excessive NOx Emissions 78-C-11
CADILLAC 
Seville 5.7L EFI EGR Passage Clogging 79-E-2
CHEVROLET 
Monte Carlo 3.8L
Monza 3.8L		 Federal, EGR Plugging, Excessive NOx Emissions 78-C-36
OLDSMOBILE 
Cutlass 3.8L (VIN A)
Delta 88 3.8L (VIN A Or 3)
Omega 3.8L (VIN A)
Starfire 3.8L (VIN A)		 Federal, EGR Valve Plugging, Excessive NOx Emissions 78-E-2
PONTIAC 
Catalina 3.8L (VIN A)
Firebird 3.8L (VIN A)
Grand Prix 3.8L (VIN A)
LeMans 3.8L (VIN A)
Phoenix 3.8L (VIN A)
Sunbird 3.8L (VIN A)		 EGR Valve Plugging, Excessive NOx Emissions 78-C-14
1979 
AMERICAN MOTORS/RENAULT 
Concord 4.2L (VIN A Or 3)
Pacer 4.2L
Spirit 4.2L		 Excessive HC & CO Emissions, EGR Valve & Vacuum Advance Replacement 8301
CADILLAC 
Eldorado 5.7L EFI
Seville 5.7L EFI		 EGR Passage Clogging 79-E-2
DODGE 
Challenger & Colt 1.4L & 1.6L Excessive HC & CO Emissions, Exceeds Calif. Emission Standard 318
      Excessive HC & CO Emissions, PCV, Carburetor & Timing Adjustment 321
PLYMOUTH 
Arrow, Champ & Sapporo 1.4L & 1.6L Excessive HC & CO Emissions, Exceeds Calif. Emission Standard 318
      Excessive HC & CO Emissions, PCV, Carburetor & Timing Adjustment 321
1980 
CHRYSLER 
Cordoba 3.7L
LeBaron 3.7L
Newport 3.7L		 Excessive HC & CO Emissions, Air Pump Outlet System Revised 351
DODGE 
Aspen 3.7L
Diplomat, Mirada & St. Regis 3.7L		 Excessive HC & CO Emissions, Air Pump Outlet System Revised 351
Colt 1.4L Excessive HC & CO Emissions, Exceeds Calif. Emission Standard 319
Colt 1.6L Excessive HC & CO Emissions, Exceeds Calif. Emission Standard 320 & 327
FORD 
LTD 5.0L & 5.8L Carburetor Stress Cracks. Replace U-6D
Fairmont (All Engines)
Mustang (All Engines)
Thunderbird (All Engines)		 Evaporative Emissions, Carbon Canister Damaged U-6C
LINCOLN 
Continental
Mark VI 5.0L & 5.8L		 Carburetor Stress Cracks. Replace U-6D
MERCURY 
Capri (All Engines)
Cougar (All Engines)
Zephyr (All Engines)		 Evaporative Emissions, Carbon Canister Damaged U-6C
Marquis 5.0L & 5.8L Carburetor Stress Cracks. Replace U-6D
PLYMOUTH 
Arrow 1.6L Excessive HC & CO Emissions, Exceeds Calif. Emission Standard 320 & 327
Champ 1.4L Excessive HC & CO Emissions, Exceeds Calif. Emission Standard 319
Champ 1.6L Excessive HC & CO Emissions, Exceeds Calif. Emission Standard 327
Gran Fury 3.7L
Volare 3.7L		 Excessive HC & CO Emissions, Air Pump Outlet System Revised 351
1981 
BUICK 
Century 4.3L (VIN S) Plugging Of Dual-Bed Bead Catalyst, Pellet Fragmentation 81-C-20
Electra 4.1L (VIN 4) Plugging Of Dual-Bed Bead Catalyst, Pellet Fragmentation 82-C-15
Electra 5.0L (VIN Y) Plugging Of Dual-Bed Bead Catalyst, Pellet Fragmentation 82-C-14
LeSabre 4.1L (VIN 4) Plugging Of Dual-Bed Bead Catalyst, Pellet Fragmentation 82-C-15
LeSabre 5.0L (VIN Y) Plugging Of Dual-Bed Bead Catalyst, Pellet Fragmentation 82-C-14
Regal 4.3L (VIN S) Plugging Of Dual-Bed Bead Catalyst, Pellet Fragmentation 81-C-20
Riviera 3.8L Turbo Incorrect Carburetor Air Inlet Duct, Increased HC Emissions 81-C-15
Riviera 4.1L (VIN 4) Plugging Of Dual-Bed Bead Catalyst, Pellet Fragmentation 82-C-15
Riviera 5.0L (VIN Y) Plugging Of Dual-Bed Bead Catalyst, Pellet Fragmentation 82-C-14
CHEVROLET 
Chevette 1.6L Excessive HC & CO, Air Tube Assembly Corrosion/Solenoid Valve Damage 81-C-24
Camaro & Caprice 3.8L (VIN K), 4.4L (VIN J), 5.0L (VIN H) & 5.7L (VIN L)
Corvette 5.7L (VIN 6)
El Camino 3.8L (VIN K), 4.4L (VIN J) & 5.0L (VIN H)
Impala 3.8L (VIN K), 4.4L (VIN J), 5.0L (VIN J) & 5.7L (VIN L)
Malibu 3.8L (VIN K), 4.4L (VIN J), 5.0L (VIN H) & 5.7L (VIN L)
Monte Carlo 3.8L (VIN K), 4.4L (VIN J), 5.0L (VIN H) & 5.7L (VIN L)		 Plugging Of Upper Bed In Dual-Bed Catalyst 82-C-31
CHRYSLER 
Cordoba 5.2L
Imperial 5.2L
LeBaron 5.2L
New Yorker 5.2L
Newport 5.2L		 Poor Solder Connection In Carburetor Bowl Vent Solenoid 292, 293
DODGE 
Aries 2.2L Excessive HC & CO Emissions, Air Bleed Control Valve Installation 375
Challenger 2.6L Excessive NOx Emissions, CARB Tested Vehicles 375
Colt 1.4L & 1.6L Excessive HC, NOx & CO, Choke & Timing Adjustment 370, 371, 372
      Exceeds Exhaust Emission Standard 370
Diplomat 5.2L
Mirada 5.2L		 Poor Solder Connection In Carburetor Bowl Vent Solenoid 292, 293
Omni 2.2L Excessive HC & CO Emissions, Air Bleed Control Valve Installation 375
St. Regis 5.2L Poor Solder Connection In Carburetor Bowl Vent Solenoid 292. 293
FORD 
Escort 1.6L Reversed Thermactor (Air Pump), Air By-Pass Vacuum Check Valve U-6M
Fairmont 2.3L Excessive HC & CO Emissions, Vacuum Delay Valve Installed E-5A
Fairmont 4.2L & 5.0L Excessive HC & CO Emissions, Leaking Choke Pull Down Motor E-5C
Granada 2.3L Excessive HC & CO Emissions, Vacuum Delay Valve Installed E-5A
Granada 4.2L & 5.0L Excessive HC & CO Emissions, Leaking Choke Pull Down Motor E-5C
LTD 4.2L & 5.0L Excessive HC & CO Emissions, Vehicle Calibration Modifications 86E53
Mustang 2.3L Excessive HC & CO Emissions, Vacuum Delay Valve Installed E-5A
Mustang 4.2L & 5.0L Excessive HC & CO Emissions, Leaking Choke Pull Down Motor E-5C
Thunderbird 4.2L & 5.0L Excessive HC & CO Emissions, Leaking Choke Pull Down Motor E-5C
MERCURY 
Capri 2.3L
Cougar 2.3L
Zephyr 2.3L		 Excessive HC & CO Emissions, Vacuum Delay Valve Installed E-5A
Capri 4.2L & 5.0L
Cougar 4.2L & 5.0L
Zephyr 4.2L & 5.0L		 Excessive HC & CO Emissions, Leaking Choke Pull Down Motor E-5C
Lynx 1.6L Reversed Thermactor (Air Pump), Air By-Pass Vacuum Check Valve U-6M
Marquis 4.2L & 5.0L Excessive HC & CO Emissions, Vehicle Calibration Modifications 86E53
OLDSMOBILE 
Custom Cruiser 5.0L (VIN Y)
Cutlass 4.3L (VIN F)
Delta 88 4.3L & 5.0L (VIN F & Y)
Ninety-Eight 4.1L (VIN 4) & 5.0L (VIN Y)
Toronado 5.0L (VIN Y)		 Plugged Dual-Bed Bead Catalyst, Pellet Fragmentation 82-E-3
Toronado 4.1L (VIN 4) Plugged Dual-Bed Bead Catalyst, Pellet Fragmentation 82-E-4
      Inoperative Fast Idle Solenoid With A/C On 81-E-2
PLYMOUTH 
Champ 1.4L & 1.6L Excessive HC, NOx & CO, Choke & Timing Adjustment 370, 371, 372
Champ 1.4L & 1.6L Federal Exceeds Exhaust Emission Standard 370
Gran Fury 5.2L Poor Solder Connection In Carburetor Bowl Vent Solenoid 292, 293
Horizon 2.2L
Reliant 2.2L		 Excessive HC & CO Emissions, Air Bleed Control Valve Installation 375
Sapporo 2.6L Excessive NOx Emissions, CARB Test Vehicles 373
PONTIAC 
Bonneville 5.0L
Parisienne 5.0L		 Plugged Dual-Bed Bead Catalyst, Pellet Fragmentation 81-C-12
Bonneville 4.3L (VIN S)
Firebird 4.3L
Grand Prix 4.3L (VIN S)
LeMans 4.3L (VIN S)		 Plugged Dual-Bed Bead Catalyst, Pellet Fragmentation 81-C-13
T1000 1.6L Excessive HC & CO, Air Tube Assembly Corrosion/Solenoid Valve Damage 81-C-15
1982 
BUICK 
Electra 4.1L (VIN 4)
LeSabre 4.1L (VIN 4)
Regal 4.1L
Riviera 4.1L (VIN 4)		 Plugged Dual-Bed Bead Catalyst, Pellet Fragmentation 82-C-15
Electra 5.0L (VIN Y)
LeSabre 5.0L (VIN Y)
Riviera 5.0L (VIN Y)		 Plugged Dual-Bed Bead Catalyst, Pellet Fragmentation 82-C-14
Skylark 1.8L (VIN G) Calif. Excessive NOx Emissions 82-C-16
CADILLAC 
Cimarron 1.8L (VIN G) Calif. Excessive NOx Emissions 82-E-3
DeVille 4.1L
Eldorado 4.1L
Fleetwood 4.1L
Seville 4.1L		 Plugged Dual-Bed Bead Catalyst, Pellet Fragmentation 83-E-1
CHEVROLET 
Camaro 5.0L (VIN H) Defective EVAP-TVS 82-C-36
      Plugged Upper Bed Of Dual-Bed Catalyst 82-C-31
Caprice 3.8L Improper Fuel Vapor Control Valve 82-C-15
Caprice 3.8L (VIN K), 4.4L (VIN J) & 5.0L (VIN H) Plugged Upper Bed In Dual-Bed Catalyst 82-C-31
Caprice 3.8L (VIN K), 4.4L (VIN J), 5.0L (VIN H) & 5.7L (VIN L) Defective EVAP-TVS 82-C-36
Cavalier 1.8L (VIN G) Calif. Excessive NOx Emissions 82-C-35
Chevette 1.6L Corrosion Of AIR Tube Assembly, Excessive HC & CO 82-C-34
El Camino 3.8L (VIN K), 4.4L (VIN J) & 5.0L (VIN H) Plugged Upper Bed In Dual-Bed Catalyst 82-C-31
      Defective EVAP-TVS 82-C-36
Impala, Malibu & Monte Carlo 3.8L Improper Fuel Vapor Control Valve 82-C-15
Impala, Malibu & Monte Carlo 3.8L (VIN K), 4.4L (VIN J), 5.0L (VIN H) & 5.7L (VIN L) Plugged Upper Bed In Dual-Bed Catalyst 82-C-31
      Defective EVAP-TVS 82-C-36
CHRYSLER 
Cordoba & Imperial 3.7L & 5.2L Incorrect VECI Label 303, 304, 305
LeBaron 2.2L Excessive HC & NOx, Timing Adjustment 408
      Excessive NOx Emissions, CARB Test Vehicles 388
LeBaron 3.7L & 5.2L
New Yorker & Newport 3.7L & 5.2L		 Incorrect VECI Label 303, 304, 305
DODGE 
Aries 2.2L Excessive HC & NOx, Timing Adjustment 408
      Excessive NOx Emissions, CARB Test Vehicles 388
      Incorrect VECI Label 311
400 2.2L Excessive HC & NOx, Timing Adjustment 408
      Excessive NOx Emissions, CARB Test Vehicles 388
Colt 1.4L Federal Exceeds Emission Standard 370
Colt 1.4L & 1.6L Excessive HC, CO & NOx, Choke & Timing Adjustment 370, 371, 372
      Excessive NOx Emissions, CARB Test Vehicles 388
Diplomat 3.7L & 5.2L
Mirada 3.7L & 5.2L		 Incorrect VECI Label 303, 304, 305
Omni 1.7L Excessive HC, Air Bleed Control Valve Added 394
Omni 2.2L Excessive HC & NOx, Timing Adjustment 408
      Excessive NOx Emissions, CARB Test Vehicles 388
FORD 
EXP 1.6L Excessive HC & CO Emissions 86E54
Escort 1.6L Excessive HC & CO Emissions 86E54
      Excessive HC Emissions, EGR Replacement & Emissions Modifications 87E59
Fairmont 2.3L Excessive NOx Emissions, Recirculation Passages Cleaned 88E66
Granada 2.3L Excessive CO Emissions, Cold Weather Modulator, Need TVS U-6W
      Excessive NOx Emissions, Recirculation Passages Cleaned 88E66
Granada 3.8L Incorrect Thermactor (Air Injection) Air Diverter Timer U-6X
LTD 4.2L & 5.0L Excessive HC & CO Emissions, Vehicle Calibration Modification 86E53
Mustang 2.3L Excessive NOx Emissions, Recirculation Passages Cleaned 86E66
Thunderbird 3.8L Excessive CO Emissions, Fails Selective Enforcement Audit U-6T
MERCURY 
Capri 2.3L Excessive NOx Emission, Recirculation Passages Cleaned 88E66
Cougar 2.3L Excessive CO Emissions, Cold Weather Modulator, Need TVS U-6W
Cougar 3.8L Excessive CO Emissions, Fails Selective Enforcement Audit U-6T
      Incorrect Thermactor (Air Injection) Air Diverter Timer U-6X
LN7 1.6L Excessive HC & CO Emissions, Vehicle Calibration Modification 86E54
Lynx 1.6L Excessive HC & CO Emissions, Vehicle Calibration Modification 86E54
      Excessive HC Emissions, EGR Replacement & Emissions Modifications 87E59
Marquis 4.2L & 5.0L Excessive HC & CO Emissions, Vehicle Calibration Modification 86E53
Zephyr 2.3L Excessive NOx Emissions, Recirculation Passages Cleaned 88E66
OLDSMOBILE 
Custom Cruiser 5.0L (VIN Y) Plugged Dual-Bed Catalyst, Pellet Fragmentation 82-E-3
Cutlass 4.3L (VIN 8) Plugged Dual-Bed Catalyst, Pellet Fragmentation 82-E-3
Delta 88 4.3L & 5.0L (VIN 8 & Y) Plugged Dual-Bed Catalyst, Pellet Fragmentation 82-E-3
Firenza 1.8L (VIN G) Calif. Excessive NOx Emissions 82-E-05
Ninety-Eight (4.1L (VIN 4) Plugged Dual-Bed Catalyst, Pellet Fragmentation 82-E-4
Ninety-Eight (5.0L (VIN Y) Plugged Dual-Bed Catalyst, Pellet Fragmentation 82-E-3
Toronado (4.1L (VIN 4) Plugged Dual-Bed Catalyst, Pellet Fragmentation 82-E-4
Toronado (5.0L (VIN Y) Plugged Dual-Bed Catalyst, Pellet Fragmentation 82-E-3
PLYMOUTH 
Champ 1.4L Federal Exceeds Emission Standard 370
Champ 1.4L & 1.6L Excessive HC, NOx & CO, Choke & Timing Adjustment 370, 371, 372
Gran Fury 3.7L & 5.2L Incorrect VECI Label 303, 304, 305
Horizon 1.7L Excessive HC, Air Bleed Control Valve Added 394
Horizon 2.2L Excessive HC & NOx, Timing Adjustment 408
      Excessive NOx Emissions, CARB Test Vehicle 388
Reliant 2.2L Excessive HC & NOx, Timing Adjustment 408
      Excessive NOx Emissions, CARB Test Vehicle 388
      Incorrect VECI Label 311
PONTIAC 
Bonneville 4.1L (VIN 4) Plugged Dual-Bed Catalyst, Pellet Fragmentation 82-C-10
Firebird 5.0L (VIN H) Defective EVAP-TVS 82-C-13
Grand Prix 4.1L (VIN 4) Plugged Dual-Bed Catalyst, Pellet Fragmentation 82-C-10
J2000 1.8L (VIN G) Calif. Excessive NOx Emissions 82-C-12
T1000 1.6L Corrosion Of PAIR Assembly, Excessive HC & CO 82-C-11
1983 
AMERICAN MOTORS/RENAULT 
Alliance 1.4L Excessive HC & CO Emissions, Air Bleed Valve Installation JE8703
BUICK 
Century 3.0L (VIN E) EGR System Vacuum Supply Hose Plugged With Glue 83-C-6
Electra, Estate Wagon & LeSabre 4.1L (VIN 4) Plugged Dual-Bed Catalytic Converter 83-C-13
Electra, Estate Wagon & LeSabre 5.0L (VIN Y) Defective EVAP-TVS 83-C-16
Regal 4.1L (VIN 4) Plugged Dual-Bed Catalytic Converter 83-C-16
Riviera 4.1L (VIN 4) Plugged Dual-Bed Catalytic Converter 83-C-13
Riviera 5.0L (VIN Y) Defective EVAP-TVS 83-C-16
Skyhawk 2.0L (VIN P) Except Federal M/T PAIR Check Valve Corrosion 83-C-14
CADILLAC 
Cimarron 2.0L (VIN P) Except Federal M/T PAIR Check Valve Corrosion 83-C-6
DeVille 4.1L
Eldorado 4.1L
Fleetwood 4.1L
Seville 4.1L		 Plugged Dual-Bed Catalytic Converter, Pellet Fragmentation 83-E-1
CHEVROLET 
Camaro 2.5L (VIN 2) 5-Speed Without A/C, Incorrect PROM 82-C-23
Camaro 5.0L (VIN H & 7) Defective EVAP-TVS 83-C-26
Caprice 3.8L Idle Speed Control Motor Wear/Pin Breakage 82-I-144
Caprice 3.8L (VIN 9), 5.0L (VIN H & 7) & 5.7L (VIN 6) Defective EVAP-TVS 83-C-26
Caprice 5.7L Police A/C Throttle Cut-Out Switch & Throttle Kicker Malfunction 83-C-18
Cavalier 2.0L (VIN P) Except Federal M/T PAIR Check Valve Corrosion 83-C-24
El Camino 3.8L (VIN 9) & 5.0L (VIN H & 7) Defective EVAP-TVS 83-C-26
Impala 3.8L (VIN 9) & 5.0L (VIN H & 7) Defective EVAP-TVS 83-C-26
Impala 5.7L Police A/C Throttle Cut-Out Switch & Throttle Kicker Malfunction 83-C-18
Malibu 3.8L (VIN 9) & 5.0L (VIN H & 7) Defective EVAP-TVS 83-C-26
Monte Carlo 3.8L (VIN 9) & 5.0L (VIN H & 7) Defective EVAP-TVS 83-C-26
CHRYSLER 
E Class 2.2L Excessive HC & NOx Emissions, CARB Test Vehicle 423
LeBaron 2.2L Excessive HC & CO Emissions, Air Bleed Control Valve Installed 420
      Excessive HC & NOx Emissions, CARB Test Vehicle 423
New Yorker 2.2L Excessive HC & NOx Emissions, CARB Test Vehicle 423
DODGE 
Aries, Charger & Omni 2.2L Excessive HC & NOx Emissions, Air Bleed Control Valve Installed 420
      Excessive HC & NOx Emissions, CARB Test Vehicle 423
Shelby 2.2L Excessive HC & NOx Emissions, CARB Test Vehicle 423
400 & 600 2.2L Excessive HC & NOx Emissions, Air Bleed Control Valve Installed 420
      Excessive HC & NOx Emissions, CARB Test Vehicle 423
FORD 
EXP 1.6L Excessive NOx 87E62
Escort 1.6L Excessive NOx 87E62
      Incorrectly Positioned Thermactor Air Supply Hose U-7E
LTD, Mustang & Thunderbird 3.8L Unacceptable HC & CO Emission Levels 88E74
MERCURY 
Capri & Cougar 3.8L Unacceptable HC & CO Emission Levels 88E74
LN7 & Lynx 1.6L Excessive NOx 87E62
Lynx 1.6L Incorrectly Positioned Thermactor Air Supply Hose U-7E
Marquis 3.8L Unacceptable HC & CO Emission Levels 88E74
OLDSMOBILE 
Custom Cruiser & Cutlass 5.0L (VIN Y & 9) Defective EVAP-TVS 83-E-05, 83-E-05A
Delta 88 5.0L (All VINs) Plugged Dual-Bed Catalyst, Pellet Fragmentation 83-E-02
Delta 88 5.0L (VIN Y & 9) Defective EVAP-TVS 83-E-05, 83-E-05A
Firenza 2.0L (VIN P) Except Federal M/T PAIR Check Valve Corrosion 83-C-09A
Ninety-Eight & Toronado 4.1L (VIN 4) Plugged Dual-Bed Catalytic Converter 83-E-03
Ninety-Eight & Toronado 5.0L (VIN Y & 9) Defective EVAP-TVS 83-E-05, 83-E-05A
PLYMOUTH 
Horizon, Reliant & Turismo 2.2L Excessive HC & CO, Air Bleed Control Valve Installed 420
      Excessive HC & NOx Emissions, CARB Test Vehicles 423
PONTIAC 
Bonneville, Firebird & Grand Prix 3.8L (VIN 9) & 5.0L (VIN H & 7) Defective EVAP-TVS 83-C-09
Parisiene 3.8L (VIN R) & 5.0L (VIN H & 7) Defective EVAP-TVS 83-C-05
1984 
AMERICAN MOTORS/RENAULT 
Alliance & Encore 1.4L Excessive HC & NOx, CARB Test Vehicles 429
BUICK 
Century 3.8L (VIN 3) Incorrect Timing Specification Listed On Underhood Label 84-C-12
Electra, LeSabre & Riviera 5.0L (VIN Y) Defective EVAP-TVS 84-C-14
Skylark 2.8L (VIN X & Z) Sticking Deceleration Valve 84-C-10
CHEVROLET 
Camaro 2.8L Without A/C Open Circuit Between ECM & Throttle Kicker Vacuum Solenoid 84-C-14
Camaro 3.8L (VIN G, H, 6 & 9) Defective EVAP-TVS 84-C-29
Camaro 5.0L (L69) High Output Ignition Coil Degradation 85-C-22
Caprice 3.8L, 5.0L & 5.7L (VIN G, H, 6 & 9) Defective EVAP-TVS 84-C-29
Celebrity & Citation 2.8L (VIN Z & 2) Sticking Deceleration Valve 84-C-18
Corvette 5.7L (L83) High Output Coil Degradation 85-C-22
El Camino 3.8L & 5.0L (VIN G, H, 6 & 9) Defective EVAP-TVS 84-C-29
Impala 3.8L, 5.0L & 5.7L (VIN G, H, 6 & 9) Defective EVAP-TVS 84-C-29
Monte Carlo 3.8L & 5.0L (VIN G, H, 6 & 9) Defective EVAP-TVS 84-C-29
Monte Carlo 5.0L (L69) High Output Ignition Coil Degradation 85-C-22
CHRYSLER 
E Class 2.2L EFI Excessive CO Emissions, O2S Malfunction 438
Laser & LeBaron 2.2L EFI Excessive CO Emissions, O2S Malfunction 438
      Excessive NOx Emissions, CARB Test Vehicles 414
New Yorker 2.2L EFI Excessive CO Emissions, O2S Malfunction 438
DODGE 
600 2.2L EFI Excessive CO Emissions, O2S Malfunction 438
      Excessive NOx Emissions, CARB Test Vehicles 414
Aries & Charger 1.6L & 2.2L EGR Valve Inoperative, EGR Valve Diaphragm Separates From Housing 354
Colt 1.4L Excessive CO Emissions, Choke & Secondary Air Adjustment 473 (419)
Daytona 2.2L EFI Excessive CO Emissions, O2S Malfunction 438
      Excessive NOx Emissions, CARB Test Vehicles 414
Omni & Rampage 1.6L & 2.2L EGR Valve Inoperative, EGR Valve Diaphragm Separates From Housing 354
FORD 
Crown Victoria 5.0L Federal Defective Catalyst 90E94
EXP & Escort 1.6L Federal Exceeds Emission Standard 90E96
      Blocked Vacuum Supply Line To Air Control Valve U-7H
      Distributor Vacuum Advance Diaphragm Leaking 87E61
LTD 3.8L Incorrect Exhaust Air Control Valve U-7J
LTD 5.0L Federal Defective Catalyst 90E94
Mustang 5.0L Federal Defective Catalyst 90E94
Tempo 2.3L HSC Modifying Emission Control Systems & Replacing Catalyst 88E67
Thunderbird 3.8L Incorrect Exhaust Air Control Valve U-7J
Thunderbird 5.0L Federal Defective Catalyst 90E94
LINCOLN 
Continental, Mark VII & Town Car 5.0L Federal Defective Catalyst 90E94
MERCURY 
Capri 5.0L Federal Defective Catalyst 90E94
Cougar 3.8L Incorrect Exhaust Air Control Valve U-7J
Cougar 5.0L Federal Defective Catalyst 90E94
Grand Marquis 5.0L Federal Defective Catalyst 90E94
Lynx 1.6L Federal Exceeds Emission Standard 90E96
      Blocked Vacuum Supply Line To Air Control Valve U-7H
      Distributor Vacuum Advance Diaphragm Leaking 87E61
Marquis 3.8L Incorrect Exhaust Air Control Valve U-7J
Topaz 2.3L HSC Modifying Emission Control Systems & Replacing Catalyst 88E67
OLDSMOBILE 
Custom Cruiser 5.0L (VIN Y & 9)
Cutlass 5.0L (VIN Y & 9)
Delta 88 5.0L (VIN Y & 9)
Ninety Eight 5.0L (VIN Y & 9)		 Defective EVAP-TVS 84-E-04
Cutlass Ciera 3.8L (VIN 3) Incorrect Timing Specifications On Underhood Label 84-E-03
Omega 2.8L (VIN X) Sticking Deceleration Valves 84-E-02
PLYMOUTH 
Colt 1.4L Excessive CO Emissions, Choke & Secondary Air Adjustment 473 (419)
Horizon, Reliant & Turismo 1.6L & 2.2L EGR Valve Inoperative, EGR Diaphragm Separated From Housing 354
PONTIAC 
6000 2.8L (VIN X & Z) Sticking Deceleration Valves 84-C-10
Firebird 2.8L Open Circuit Between ECM & Throttle Kicker Vacuum Solenoid 84-C-07
Firebird 5.0L (VIN G & H) Defective EVAP-TVS 84-C-14
Firebird 5.0L (L69) High Output Ignition Coil Degradation 85-C-10
Grand Prix 5.0L (VIN G & H) Defective EVAP-TVS 84-C-14
Parisiene 5.0L (VIN G & H) Defective EVAP-TVS 84-C-14
1985 
AMERICAN MOTORS/RENAULT 
Alliance & Encore 1.4L Excessive EVAP Emissions, Cracked Fuel Tank Vent Hose 433
Alliance & Encore 1.7L Catalytic Converter Erosion, No Insulation Blanket. Replace Converter 545
      Ceramic Catalyst Contents Breakdown. Replace Converter 459
BUICK 
Century & Electra 3.0L & 3.8L MFI V8 Excessive CO 85-C-18
Electra & Park Avenue 4.3L (VIN 3) Missing SERVICE ENGINE SOON Light Bulb 85-C-13
Regal & Riviera 3.8L (VIN 9) Incorrect Intake Manifold Gasket, Inhibits EGR Function 85-C-6
Somerset Regal 3.0L & 3.8L V6 MFI Excessive CO 85-C-18
CHEVROLET 
Camaro (L69 & LB9)
Corvette 5.7L (L98)
Monte Carlo 5.0L (L69)		 High Output Ignition Coil Degradation 85-C-22
Corvette 5.7L Engine Stall, Defective MAF Sensor 85-C-12
Nova 1.6L No-Start, Defective Ignition Control Module 85-C-29
CHRYSLER 
Fifth Avenue & Newport 5.2L 2-Bbl. Excessive NOx Emissions, CARB Test Vehicles 374
DODGE 
Aries, Charger & Omni 2.2L Excessive HC & CO, Choke Delay Valve Failure 448
Colt 1.5L Excessive CO Emissions, Choke & Secondary Air Adjustment 474 (427)
Colt Vista 2.0L Excessive HC & CO Emissions, CARB Test Vehicles 2907
Diplomat 5.2L 2-Bbl. Excessive NOx Emissions, CARB Test Vehicles 374
FORD 
Crown Victoria 5.0L Federal Defective Catalyst 90E94
EXP 1.6L Federal Exceeds Emission Standard 90E96
EXP 1.9L Does Not Meet Federal Emission Levels 89E76
Escort 1.6L Federal Exceeds Emission Standard 90E96
      Does Not Meet Federal Exhaust Emission Levels 89E76
Escort 1.9L Calif. Non-Conformance, HC & NOx (Non-Methane) 88E71
LTD, Mustang & Thunderbird 3.8L Excessive Emissions. Replace Catalytic Converter & Pipe 88E73
      Unacceptable HC Emission Levels. Replace AIR Control Valve 89E77
LTD, Mustang & Thunderbird 5.0L Federal Defective Catalyst 90E94
Tempo/Topaz 2.3L CFI & HO Excessive Emissions, Emission Control Component/System 89E78
LINCOLN 
Continental, Mark VII & Town Car 5.0L Federal Defective Catalyst 90E94
MERCURY 
Capri & Cougar 3.8L Excessive Emissions. Replace Exhaust System/Catalytic Converter/Pipe 88E73
      Unacceptable HC Emission Levels. Replace AIR Control Valve 89E77
Capri & Cougar 5.0L Federal Defective Catalyst 90E94
Grand Marquis Victoria 5.0L Federal Defective Catalyst 90E94
Lynx 1.6L Federal Exceeds Emission Standard 90E96
Lynx 1.6L Calif. Emission Non-Conformance, HC & NOx (Non-Methane) 88E71
      Does Not Meet Federal Emission Levels 89E76
Marquis 3.8L Excessive Emissions. Replace Exhaust System/Catalytic Converter/Pipe 88E73
      Unacceptable HC Emission Levels. Replace AIR Control Valve 89E77
OLDSMOBILE 
Calais, Custom Cruiser, Cutlass Ciera & Ninety-Eight 3.0L & 3.8L MFI V6 Excessive CO 85-E-01
PLYMOUTH 
Colt 1.5L Excessive CO Emissions, Choke & Secondary Air Adjustment 474 (427)
Colt Vista 2.0L Excessive HC & CO, CARB Test Vehicle 290T
Gran Fury 5.2L 2-Bbl. Excessive NOx Emissions, CARB Test Vehicle 374
Horizon, Reliant & Turismo 2.2L Excessive HC & CO, Choke Delay Valve Failure 448
PONTIAC 
Fiero 2.8L V6 EGR Pipe Cracks 87-6-23
Firebird 5.0L Calif. & 5.7L High Output Ignition Coil Degradation 85-C-10
Firebird 5.0L Fuel Tank Pressure Control Valve Installed Backwards 85-C-06
Grand Am 3.0L & 3.8L V6 MFI Excessive CO 85-C-12
1986 
AMERICAN MOTORS/RENAULT 
Alliance & Encore 1.4L Ceramic Catalyst Breakdown, Catalytic Converter Replacement 461
Alliance & Encore 1.7L Catalytic Converter Erosion, No Insulation Blanket Replacement Converter 454
      Ceramic Catalyst Contents Breakdown, Catalytic Converter Replacement 459
CADILLAC 
Fleetwood Brougham 5.0L Carburetor Throttle Shaft Twisted 86-E-1
CHEVROLET 
Caprice Classic Wagon 5.0L (LV2) Carburetor Throttle Shaft Twisted 86-C-21
Celebrity 2.8L (LB6) Inoperative Cold Start Injector 86-C-07
Chevette 1.6L (L4) Incorrect Distributor Fairchild Module 86-C-08
Corvette 5.7L Defective Fuel Tank Pressure Control Valve 86-C-26
Monte Carlo SS 5.0L (L69) Improper Carburetor Float Needle Valve Seat 86-C-04
CHRYSLER 
Laser & LeBaron 2.2L & 2.5L EFI Fuel Injectors Shift Rich 397
      Incorrect VECI Label 462
LeBaron GTS 2.2L EFI Excessive Emissions, Wrong Catalytic Converter 378
LeBaron 2.2L & 2.5L EFI Fuel Injectors Shift Rich 397
      Incorrect VECI Label 462
New Yorker 2.2L & 2.5L EFI Fuel Injectors Shift Rich 397
      Incorrect VECI Label 462
DODGE 
Aries & 600 2.2L & 2.5L EFI Fuel Injectors Shift Rich 397
      Incorrect VECI Label 462
Charger 2.2L & 2.5L Incorrect VECI Label 462
Charger 2.2L Excessive HC & CO Emissions 500, 501
Colt 1.5L Excessive CO, CARB Test Vehicle 464
      Excessive CO, Inadequate Choke Opening 469
Colt Vista 2.0L Excessive HC, CO & NOx, Inadequate Choke Opening (Non-Electric Choke) 478
      Excessive HC & CO, CARB Test Vehicle 472
      Excessive HC & CO, Inadequate Choke Opening 294T
Colt Vista 2.0L Excessive HC, CO & NOx Emissions, CARB Test Vehicle 285T
Daytona 2.2L & 2.5L EFI Fuel Injectors Shift Rich 397
      Incorrect VECI Label 462
Lancer 2.2L EFI Excessive Emissions, Wrong Catalytic Converter 378
Lancer 2.2L & 2.5L EFI Fuel Injectors Shift Rich 397
      Incorrect VECI 462
Omni 2.2L Excessive HC & CO Emissions 500, 501
Omni 2.2L & 2.5L Incorrect VECI Label 462
Shadow 2.2L & 2.5L EFI Fuel Injectors Shift Rich 397
FORD 
Crown Victoria 5.0L Does Not Meet Calif. Exhaust HC Emission Standard 89E79
Escort & EXP 1.9L (Calif. A/T) Exceeds HC & NOx Emission Standard 89E81
Escort & EXP 1.9L (Federal) Exceeds CO & NOx Emissions Standard 91E17
Escort & EXP 1.9L Does Not Meet Federal Exhaust Emissions Level 89E76
      Excessive CO Emissions, Revise Vacuum Supply Assembly 86E55
LTD, Mustang & Thunderbird 3.8L (Federal) Exceeds HC & CO Emissions Standard 90E88
LTD, Mustang & Thunderbird 3.8L (Calif.) Excessive Emissions. Replace Exhaust System Catalytic Converter & Pipe 88E73
      Unacceptable HC Emission Levels, AIR Control Valve Replacement 89E77
      Unacceptable Non-Methane HC Emission Level 89E83
LTD, Mustang & Thunderbird 5.0L Does Not Meet Calif. Exhaust HC Emissions Standard 89E79
Taurus/Sable 2.5L CFI Excessive Emissions, Emission Control Component/System 89E78
Tempo/Topaz 2.3L CFI & HO Excessive Emissions, Emission Control Component/System 89E78
Mark VII & Town Car 5.0L CFI Excessive Emissions, Emission Control Component/System 89E78
MERCURY 
Capri & Cougar 3.8L (Federal) Exceeds HC & CO Emissions Standard 90E88
Capri & Cougar 3.8L (Calif.) Excessive Emissions, Exhaust System Catalytic Converter & Pipe 88E73
      Unacceptable HC Emission Levels, AIR Control Valve Replacement 89E77
      Unacceptable Non-Methane HC Emission Level 89E83
Cougar 5.0L Does Not Meet Calif. Exhaust HC Emissions Standard 89E79
Grand Marquis 5.0L Does Not Meet Calif. Exhaust HC Emissions Standard 89E79
Lynx 1.9L Calif. A/T Only, Exceeds HC & NOx Emissions Standard 89E81
      Does Not Meet Calif. HC & NOx Emissions (Non-Methane) 88E71
      Does Not Meet Federal Exhaust Emissions Level 89E76
      Exceeds Emissions Standard For CO & NOx 91E17
      Excessive CO Emissions, Revised Vacuum Supply Assembly 86E55
Marquis 3.8L Federal Only, Exceeds HC & CO Emissions Standard 90E88
      Excessive Emissions, Exhaust System Catalytic Converter & Pipe 88E73
      Unacceptable HC Emission Levels, AIR Control Valve Replacement 89E77
      Unacceptable Non-Methane HC Emission Level 89E83
OLDSMOBILE 
Calais 2.5L (L68) & 3.0L (LN7) Missing UNLEADED FUEL ONLY Decal On Panel 86-E-03
Custom Cruiser Wagon 5.0L Carburetor Throttle Shaft Twisted 86-E-04
Cutlass Ciera 2.8L (VIN W) Inoperative Cold Start Injector 86-E-02
Cutlass Ciera 2.8L (VIN X) Inoperative Fast Idle Solenoid Relay Assembly 86-E-01
PLYMOUTH 
Caravelle 2.2L & 2.5L EFI Fuel Injectors Shift Rich 397
      Incorrect Emission Control Label, Shows Air Injection Valve 462
Colt 1.5L Excessive CO, CARB Test Vehicle 464
      Excessive CO, Inadequate Choke Opening 469
Colt Vista 2.0L Excessive HC, CO & NOx, Inadequate Choke Opening (Non-Electric Choke) 478
      Excessive HC & CO, CARB Test Vehicle 472
      Excessive HC & CO, Inadequate Choke Opening 294T
      Excessive HC, CO & NOx, CARB Test Vehicle 285T
Horizon 2.2L Excessive HC & CO Emissions 500, 501
Horizon 2.2L & 2.5L Incorrect Emission Control Label, Shows Air Injection Valve 462
Reliant 2.2L & 2.5L EFI Fuel Injectors Shift Rich 397
      Incorrect Emission Control Label, Shows Air Injection Valve 462
Turismo 2.2L Excessive HC & CO Emissions 500, 501
Turismo 2.2L & 2.5L Incorrect Emission Control Label, Shows Air Injection Valve 462
PONTIAC 
T1000 1.6L (L4) Incorrect Distributor Fairchild Module 86-C-04
6000 2.8L (LB6) Inoperative Cold Start Injector 86-C-05
1987 
AMERICAN MOTORS/RENAULT 
Alliance & Encore 2.0L Catalytic Converter Erosion, No Insulation Blanket. Replace Converter 454
Eagle 4.2L Excessive HC, CO & NOx Emissions. Replace Catalytic Converter 312T
GTA 1.7L Ceramic Catalyst Breakdown. Replace Catalytic Converter 459
BUICK 
Century & LeSabre (LG3) Cracked MAF Sensor Conductive Nickel Bus Bar. Replace Sensor 87-C-02
Regal 3.8L Turbo Excessive CO Emissions 87-C-14
Skylark & Somerset 3.0L (LN7) Cracked MAF Sensor Conductive Nickel Bus Bar. Replace Sensor 87-C-02
CHEVROLET 
Monte Carlo 5.0L (VIN G) Torque Converter Clutch Erratic 87-C-08
CHRYSLER 
Conquest 2.2L & 2.5L Incorrect VECI Label, Shows Air Injection Valve 462
Conquest 2.2L & 2.5L (Federal) Excessive CO Emissions. Replace Catalytic Converter 523
Conquest 2.6L Turbo (Calif.) Replace With Improved Front Catalytic Converter 524
Fifth Avenue 5.2L Computer/Transmission Kickdown Lever & Rod Replacement 515
Fifth Avenue 5.2L (Fed. & Hi-Alt.) Exceeds HC & CO Emissions Standard 515
LeBaron 2.2L & 2.5L Incorrect VECI Label, Shows Air Injection Valve 462
LeBaron 2.5L Excessive CO, Rich Shifted Fuel Injectors 480
LeBaron GTS 2.2L & 2.5L Incorrect VECI Label, Shows Air Injection Valve 462
New Yorker 2.2L & 2.5L Incorrect VECI Label, Shows Air Injection Valve 462
New Yorker 2.5L Excessive CO, Rich Shifted Fuel Injectors 480
Newport 5.2L Computer/Transmission Kickdown Lever & Rod Replacement 515
DODGE 
Aries & 600 2.2L & 2.5L Incorrect VECI Label, Shows Air Injection Valve 462
Aries 2.5L Excessive CO, Rich Shifted Fuel Injectors 480
Charger 2.2L Excessive NOx Emissions, Install Spark Advance Vacuum Modulator 543
Charger 2.2L & 2.5L Incorrect VECI Label, Shows Air Injection Valve 462
Colt 1.5L Excessive CO Emissions, Install Vacuum Control Valve & Harness 483
Colt 2.2L & 2.5L Incorrect VECI Label, Shows Air Injection Valve 462
Colt Vista 2.0L Excessive HC, CO & NOx, Inadequate Choke Opening (Non-Electric Choke) 478
      Excessive HC & CO Emissions, CARB Test Vehicle 294T
Colt Vista 2.2L & 2.5L Incorrect VECI Label, Shows Air Injection Valve 462
Daytona & Lancer 2.2L & 2.5L Incorrect VECI Label, Shows Air Injection Valve 462
Daytona & Lancer 2.5L Excessive CO Emissions, Rich Shifted Fuel Injectors 480
Diplomat 5.2L Computer/Transmission Kickdown Lever & Rod Replacement 515
      Federal & High Alt., Exceeds HC & CO Emissions Standard 515
Omni 2.2L Excessive NOx, Install Spark Advance Vacuum Modulator 543
Omni 2.2L & 2.5L Incorrect VECI Label, Shows Air Injection Valve 462
Raider & Shadow 2.2L & 2.5L Incorrect VECI Label, Shows Air Injection Valve 462
FORD 
Escort, EXP & Lynx 1.9L CPI Excessive Emissions, Emission Control Component/System 89E78
Mustang 2.3L Exceeds Calif. Emissions Standard 91E01
Mustang 5.0L Omitted Fuel Vapor Restrictor In Canister Purge Line 87E60
Taurus 3.0L (Federal) Replace Catalytic Converter 91E10
Taurus & Sable 2.5L CFI Excessive Emissions, Emissions Control Component/System 89E78
Tempo & Topaz 2.3L CFI & HO Excessive Emissions, Emissions Control Component/System 89E78
Thunderbird & Cougar 3.8L (Federal) Exceeds CO Emissions Standard 90E89
Sable (Federal) Replace Catalytic Converter 91E10
OLDSMOBILE 
Calais 2.3L Quad IV IDI Coil Arcing, Causes Rough Idle 90-E-01
Calais 3.0L (LN7) Cracked MAF Sensor Conductive Nickel Bus Bars 87-E-01
Delta 88 & Ninety-Eight 3.8L (LN7) Cracked MAF Sensor Conductive Nickel Bus Bars 87-E-01
PLYMOUTH 
Caravelle 2.2L & 2.5L Incorrect VECI Label, Shows Air Injection Valve 462
Colt 1.5L Excessive CO Emissions, Install Vacuum Control Valve & Harness 483
Colt 2.2L & 2.5L Incorrect VECI Label, Shows Air Injection Valve 462
Colt Vista 2.0L Excessive HC, CO & NOx, Inadequate Choke Opening (Non-Electric Choke) 478
      Excessive HC & CO Emissions, CARB Test Vehicle 472
Colt Vista 2.2L & 2.5L Incorrect VECI Label, Shows Air Injection Valve 462
Gran Fury 5.2L Computer/Transmission Kickdown Lever & Rod Replacement 515
      Federal & High Alt., Exceeds HC & CO Emissions Standard 515
Horizon 2.2L Excessive NOx, Install Spark Advance Vacuum Modulator 543
Horizon 2.2L & 2.5L Incorrect VECI Label, Shows Air Injection Valve 462
Reliant 2.2L & 2.5L Incorrect VECI Label, Shows Air Injection Valve 462
Reliant 2.5L Excessive CO, Rich Shifted Fuel Injectors 480
Sundance 2.2L & 2.5L EFI Fuel Injectors Shift Rich 397
      Incorrect VECI Label, Shows Air Injection Valve 462
Turismo 2.2L Excessive NOx, Install Spark Advance Vacuum Modulator 543
Turismo 2.2L & 2.5L Incorrect VECI Label, Shows Air Injection Valve 462
Grand Am 3.0L (VIN L) Cracked MAF Sensor Conductive Nickel Bus Bar 87-C-01
1988 
BUICK 
Skylark 2.3L Quad IV IDI Coil Arcing, Causing Rough Idle 90-C-11
CHRYSLER 
Conquest 2.6L Turbo (Federal) Excessive CO Emissions. Replace Catalytic Converter 524
Conquest 2.6L Turbo (Calif.) Replace Front Catalytic Converter 523
FORD 
Escort 1.9L (Calif.) Exceeds NOx Emissions Standard 91E12
Taurus 3.8L (Federal) Exceeds HC Emissions Standard 91E16
Taurus 3.8L Exceeds HC & NOx Emissions Standard (After 91E15 Recall) 93E41
      Exceeds HC & NOx Emissions Standard (Before 91E15 Recall) 93E42
Tempo 2.3L Exceeds NOx Emissions Standard. Replace Catalytic Converter 91E07
LINCOLN 
Continental 3.8L (Federal) Exceeds HC Emissions Standard 91E16
Continental 3.8L Exceeds HC & NOx Emissions Standard (After 91E15 Recall) 93E41
      Exceeds HC & NOx Emissions Standard (Before 91E15 Recall) 93E42
MERCURY 
Sable 3.8L (Federal) Exceeds HC Emissions Standard 91E16
Sable 3.8L Exceeds HC & NOx Emissions Standard (After 91E15 Recall) 93E41
      Exceeds HC & NOx Emissions Standard (Before 91E15 Recall) 93E42
Topaz 2.3L (Calif.) Exceeds NOx Emissions Standard. Replace Catalytic Converter 91E07
Tracer 1.6L Spark Plug Wire Abrasion Wear On Inlet Tube 88E75
MERKUR 
Scorpio 2.9L Vehicle Speed Sensor Malfunction, Faulty Throttle Body 87E63
OLDSMOBILE 
Calais 2.3L Quad IV IDI Coil Arcing, Causing Rough Idle 90-E-01
PONTIAC 
Grand Am 2.3L Quad IV IDI Coil Arcing, Causing Rough Idle 90-C-01
1989 
BUICK 
Skylark 2.3L Quad IV IDI Coil Arcing, Causing Rough Idle 90-C-01
CHEVROLET 
Beretta, Cavalier & Corsica 2.0L Vehicle Distributor Error 89-C-19
CHRYSLER 
Conquest 2.6L Turbo (Federal) Excessive CO Emissions. Replace Catalytic Converter 523
Conquest 2.6L Turbo (Calif.) Replace Front Catalytic Converter 524
LeBaron 2.5L Wrong Engine Controller Software 450
TC 2.2L Turbo Incorrect VECI Label 457
DODGE 
Daytona & Shadow Wrong Engine Controller Software 450
FORD 
Escort 1.9L (Calif.) Exceeds NOx Emissions Standard 91E12
Festiva 1.3L Malfunction Indicator Light Improperly Illuminates 91E02
Taurus 3.8L Exceeds HC Emissions Standard 91E16
Tempo 2.3L (Calif.) Exceeds NOx Emissions Standard. Replace Catalytic Converter 91E07
Thunderbird Disconnected Vapor Hose 92E22
GEO 
Metro & Tracker Vehicle Distribution Error Outside California 89-C-20
LINCOLN 
Continental 3.8L Exceeds HC Emissions Standard 91E16
MERCURY 
Cougar 3.8L Disconnected Vapor Hose 92E22
Sable 3.8L Exceeds HC Emissions Standard 91E16
Topaz 2.3L (Calif.) Exceeds NOx Emissions Standard. Replace Catalytic Converter 91E07
OLDSMOBILE 
Calais 2.3L Quad IV IDI Coil Arcing, Causing Rough Idle 90-E-01
PLYMOUTH 
Sundance 2.5L Wrong Engine Controller Software 450
PONTIAC 
Grand Am 2.3L Quad IV IDI Coil Arcing, Causing Rough Idle 90-C-11
1990 
BUICK 
Skylark 2.3L Quad IV IDI Coil Arcing, Causing Rough Idle 90-C-11
CHEVROLET 
Caprice Vehicle Test Weight Failure 90-C-28
Lumina 3.1L V6 Incorrect ECM & VECI Label 90-C-01
DODGE 
Omni & Shadow Incorrect VECI Label 516
EAGLE 
Summit 1.6L DOHC Inaccurate Vacuum Hose Routing Label, Hoses Reversed 460
FORD 
Probe 3.0L (A/T) Exceeds CO Emissions Standard 91E08
      Defective TP Sensor 92E21
Taurus 3.8L Exceeds HC Emissions Standard 91E16
Tempo 2.3L Premature Wear On TP Sensor 91E09
LINCOLN 
Continental 3.8L Exceeds HC Emissions Standard 91E16
MERCURY 
Sable 3.8L Exceeds HC Emissions Standard 91E16
Topaz 2.3L Premature Wear On TP Sensor 91E09
OLDSMOBILE 
Calais & Cutlass Supreme 2.3L Quad IV IDI Coil Arcing, Causing Rough Idle 90-E-01
PLYMOUTH 
Horizon 2.2L Incorrect VECI Label 561
Laser 1.8L, 2.0L & 2.0L Turbo Incorrect VECI Label 458
Sundance 2.2L Incorrect VECI Label 514
PONTIAC 
Grand Am & Grand Prix 2.3L Quad IV IDI Coil Arching, Causing Rough Idle 90-C-11
1991 
DODGE 
Omni & Shadow 2.2L Incorrect VECI Label 561, 517
Spirit 2.2L Turbo II PCV Vacuum Hose Orifice, Oil Leakage 499
EAGLE 
Talon 2.0L Turbo (Calif.) Excessive HC & CO Emissions. Replace O2S 533
Talon 2.0L Turbo (Federal) Excessive HC & CO Emissions. Replace O2S 534
FORD 
Probe 3.0L Defective TP Sensor 92E21
Tempo 2.3L Premature Wear On TP Sensor 91E09
GEO 
Storm 1.6L CHECK ENGINE Light ON, Incorrect ECM Resistor 91-C-06
LINCOLN 
Town Car 4.6L Incorrect Bar Code Information On Emission Control/Engine Label 91E06
MERCURY 
Cougar 1.6L Incorrect Bar Code Information On Emission Control/Engine Label 91E06
Topaz 2.3L Premature Wear On TP Sensor 91E09
PLYMOUTH 
Horizon 2.2L Incorrect Vehicle Information On Emission Control Label 516
Laser 2.0L Turbo (Calif.) Excessive HC & CO Emissions. Replace O2S 533
Laser 2.0L Turbo (Federal) Excessive HC & CO Emissions. Replace O2S 534
PONTIAC 
LeMans 2.0L Incorrect Vehicle Distribution, MEM-CAL Label 91-C-05
1992 
CHEVROLET 
Corvette 5.7L Internal Distributor Component Corrosion 92-C-11
CHRYSLER 
LeBaron 2.5L Turbo Incorrect Information On VECI Label 531
DODGE 
Daytona 2.5L Turbo Incorrect Information On VECI Label 531
Shadow 2.2L Incorrect Information On VECI Label 530, 532
Shadow 2.5L Turbo Incorrect Information On VECI Label 531
Shadow 2.5L Non-Turbo Incorrect Information On VECI Label 529
Spirit 2.5L Turbo Incorrect Information On VECI Label 531
Spirit 2.5L Non-Turbo Incorrect Information On VECI Label 529
EAGLE 
Talon 2.0L Turbo (Calif.) Excessive HC & CO Emissions. Replace O2S 533
Talon 2.0L Turbo (Federal) Excessive HC & CO Emissions. Replace O2S 534
FORD 
Crown Victoria Install Shield Kit To Protect Fuel Tank In Rear Impact Crashes 021003000
Taurus 3.8L Incorrect EEC Processor 92E29
Thunderbird 3.8L Incorrect EEC Processor 92E24
Thunderbird 3.8L & 5.0L Worn EVAP Fuel Line 97-S-84
MERCURY 
Cougar 3.8L Incorrect EEC Processor 92E24
Cougar 3.8L & 5.0L Worn EVAP Fuel Line 97-S-84
Sable 3.8L Incorrect EEC Processor 92E29
LINCOLN 
Town Car 3.8L Incorrect EEC Processor 92E20
PLYMOUTH 
Acclaim 2.5L Turbo Incorrect Information On VECI Label 531
Acclaim 2.5L Non-Turbo Incorrect Information On VECI Label 529
Laser 2.0L Turbo (Calif.) Excessive HC & CO Emissions. Replace O2S 533
Laser 2.0L Turbo (Federal) Excessive HC & CO Emissions. Replace O2S 533, 534
Sundance 2.2L Incorrect Information On VECI Label (A/T) 532
      Incorrect Information On VECI Label (Except A/T) 530
Sundance 2.5L Incorrect Information On VECI Label 529, 531
PONTIAC 
Sunbird 2.0L Faulty Crankcase Vent System Hose 92-C-51
1993 
CHEVROLET 
Camaro 5.7L DTC 29 Or DTC 410, Blown Air Pump Fuse. Replace Wiring & Fuse 63-65-02
CADILLAC 
Concours, DeVille, Eldorado & Seville 4.6L (VIN Y) Wrong PCV Valve Installed 96-C-28
DODGE 
Spirit 2.5L Flex-Fuel Reprogram PCM & Replace VECI Label 716
      Faulty Methanol Concentration Sensor 797
FORD 
Tempo 3.0L EVAP Lines Not Connected 93-E-32
Thunderbird 3.8L & 5.0L Worn EVAP Fuel Line 97-S-84
MERCURY 
Cougar 3.8L & 5.0L Worn EVAP Fuel Line 97-S-84
Topaz 3.0L EVAP Line Not Connected 93-E-32
PLYMOUTH 
Acclaim 2.5L Flex-Fuel Reprogram PCM & Replace Underhood VECI Label 716
      Faulty Methanol Concentration Sensor 797
PONTIAC 
Firebird 5.7L DTC 29 Or DTC 410, Blown Air Pump Fuse. Replace Wiring & Fuse 63-65-02
1994 
BUICK 
Skylark High Current Flows Through Ignition Switch, Install Relay Kit 00V287000
CHEVROLET 
Camaro 5.7L DTC 29 Or DTC 410, Blown Air Pump Fuse. Replace Wiring & Fuse 63-65-02
CHRYSLER 
Concorde 3.3L Flex-Fuel Faulty Methanol Concentration Sensor 797
DODGE 
Intrepid 3.3L Flex Fuel
Spirit 2.5L Flex-Fuel		 Faulty Methanol Concentration Sensor 797
EAGLE 
Vision 3.3L Flex-Fuel Faulty Methanol Concentration Sensor 797
OLDSMOBILE 
Achieva High Current Flows Through Ignition Switch, Install Relay Kit 00V287000
PLYMOUTH 
Acclaim 2.5L Flex-Fuel Faulty Methanol Concentration Sensor 797
PONTIAC 
Firebird 5.7L DTC 29 Or DTC 410, Blown Air Pump Fuse. Replace Wiring & Fuse 63-65-02
Grand Am High Current Flows Through Ignition Switch, Install Relay Kit 00V287000
SATURN 
1.9L Catalytic Converter Failure ML-GM680
1995 
BUICK 
Skylark High Current Flows Through Ignition Switch, Install Relay Kit 00V287000
CHEVROLET 
Cavalier 2.2L (VIN 4) Incorrect VECI Label Installed 95-C-30
Camaro 5.7L DTC 29 & DTC 410, Blown Air Pump Fuse. Replace Wiring & Fuse 63-65-02
CHRYSLER 
Concorde 3.3L Flex-Fuel Faulty Methanol Concentration Sensor 797
DODGE 
Intrepid 3.3L Flex-Fuel Faulty Methanol Concentration Sensor 797
EAGLE 
Vision 3.3L Flex-Fuel Faulty Methanol Concentration Sensor 797
FORD 
Contour 2.0L Surge, Rough Idle, Poor Mileage. Replace O2 Sensor 97-23-2
Contour 2.5L Faulty Catalytic Converter. Replace Converter 96-E-60 & 97-E-61
Contour Fraying Or Separation Of Throttle Cable. Replace Cable 97V225000
Escort 1.9L Cracked Fuel Tank, Causing High EVAP Emissions. Replace Tank 97S79 & 97S80
Mustang & Taurus Seized Engine Cooling Fan, Inspect & Install Circuit Breaker. Replace Fan If Needed 01V390
Probe 2.5L Replace Fuel Filler Cap 99E02
MERCURY 
Mystique 2.0L Surge, rough Idle, Poor Mileage. Replace O2 Sensor 97-23-2
Mystique 2.5L Replace Faulty Catalytic Converter 96-E-60 & 97-E-61
Mystique Fraying Or Separation Of Throttle Cable. Replace Cable 97V225000
Sable Seized Engine Cooling Fan, Inspect & Install Circuit Breaker. Replace Fan If Needed 01V390
Tracer 1.9L Cracked Fuel Tank, Causing High EVAP Emissions. Replace Tank 97S79 & 97S80
OLDSMOBILE 
Achieva High Current Flows Through Ignition Switch, Install Relay Kit 00V287000
PONTIAC 
Firebird 5.7L DTC 29 Or DTC 410, Blown Air Pump Fuse. Replace Wiring & Fuse 63-65-02
Grand Am High Current Flows Through Ignition Switch, Install Relay Kit 00V287000
1996 
BUICK 
Skylark 2.4L (VIN T) Incorrect EVAP Purge Control Solenoid 97010
CHEVROLET 
Beretta, Cavalier & Corsica 2.2L (VIN 4) Fuel Injector Plastic Encapsulation Stress 96-C-32
Camaro 5.7L DTC 29 Or DTC 410, Blown Air Pump Fuse. Replace Wiring & Fuse 63-65-02
Impala & Monte Carlo 3.4L MIL Illuminated Due To Faulty Spark Plug Wires SM-2948
CHRYSLER 
Cirrus 2.4L & 2.5L OBD-II Readiness Codes May Be Cleared (Calif.), Reprogram PCM 678
Cirrus 2.4L High CO Emissions During I/M Testing, Reprogram PCM 758
Concord & LHS 3.3L & 3.5L OBD-II Readiness Codes May Be Cleared (Calif.), Reprogram PCM 678
Concord 3.5L Wrong VECI Label 802
Sebring 2.5L Faulty Throttle Control Cable. Replace Cable Assembly 02V186000
Sebring Convertible 2.4L High CO Reading During I/M Testing, Reprogram PCM 75
DODGE 
Intrepid 3.5L Wrong VECI Label 802
Intrepid 3.3L & 3.5L OBD-II Readiness Codes May Be Cleared (Calif.). Reprogram PCM 678
Stealth 3.0L Turbo Incorrect Underhood Vacuum Hose Routing Label 692
Stratus 2.0L (M/T) OBD System Disabled Purge Flow Detection 792
Stratus 2.0L, 2.4L & 2.5L OBD-II Readiness Codes May Be Cleared (Calif.). Reprogram PCM 678
Stratus 2.4L High CO Emissions During I/M Testing, Reprogram PCM 758
Viper GTS 8.0L (Calif.) Incorrect Downstream O2S Wiring 725 & 726
300M Incorrect VECI Label 802
EAGLE 
Vision 3.3L & 3.5L OBD-II Readiness Codes May Be Cleared (Calif.). Reprogram PCM 678
FORD 
Contour Replace Low Ozone Resistance Fuel Filler Vent Hose 99V247000
      Fraying Or Separation Of Throttle Cable. Replace Cable Assembly 97V225000
Contour 2.0L Surge, Rough Idle, Poor Mileage. Replace O2 Sensor 97-23-2
Contour 2.5L Replace Faulty Catalytic Converter 96-E-60 & 97-E-61
Probe 2.5L Replace Fuel Filler Cap 99E02
Taurus (Flex-Fuel) Faulty Fuel Control Valve & Fuel Tank Vent Valve 96-E-59
Taurus Wrong Fuel Tank Size, Install 16 Gallon Tank 98V067000
MERCURY 
Mystique Replace Low Ozone Resistance Fuel Filler Vent Hose 99V247000
      Fraying Or Separation Of Throttle Cable. Replace Cable Assembly 97V225000
Mystique 2.0L Surge, Rough Idle, Poor Mileage. Replace O2 Sensor 97-23-2
Mystique 2.5L Replace Faulty Catalytic Converter 96-E-60 & 97-E-61
Sable Replace Wrong Size Fuel Tank, Install 16 Gallon Tank 98V067000
PLYMOUTH 
Breeze 2.0L OBD-II Readiness Codes May Be Cleared (Calif.). Reprogram PCM 578
Breeze 2.4L High CO Emissions During I/M Testing, Reprogram PCM 758
PONTIAC 
Firebird 5.7L DTC 29 Or DTC 410, Blown Air Pump Fuse. Replace Wiring & Fuse 63-65-02
Grand Am 2.4L (VIN T) Incorrect EVAP Purge Control Solenoid 97010
Sunfire 2.2L (VIN 4) Fuel Injector Plastic Encapsulation Stress 96-C-32
CHEVROLET 
Impala, Lumina & Monte Carlo 3.8L VECI Shows Reversed Vacuum Connection To Canister Purge Solenoid SM-2927
1997 
CHEVROLET 
Corvette 5.7L Reduced Power, Stall & DTC P1518. Reprogram PCM 97040
Impala & Monte Carlo 3.4L MIL Illuminated Due To Faulty Spark Plug Wires SM-2948
CHRYSLER 
Viper 8.0L Reversed Rear O2S Wiring, May Cause False MIL Illumination 725 & 726
GEO 
Metro Shift Lever Can Slip From Park & Vehicle Can Roll. Replace Shifter Assembly 98V225000
1998 
BUICK 
LeSabre & Park Avenue 3.8L (VIN K) Faulty Spark Plug, PCM Reflash 98003
LeSabre 3.8L VECI Label Shows Incorrect Vacuum Hose Connections To Canister Purge Solenoid SM-2926
CADILLAC 
DeVille & Eldorado 4.6L Misrouted Canister Purge Evaporative Harness 97V183000
CHEVROLET 
Impala, Lumina & Monte Carlo 3.8L VECI Label Shows Reversed Vacuum Hose Connections To Canister Purge Solenoid SM-2927
CHRYSLER 
Cirrus (All Engines) Inoperative OBD EVAP Purge Monitor 803
Cirrus 2.7L & 3.2L Reflash PCM For EVAP Purge Monitor 814
Concord 2.7L & 3.2L Reflash PCM For EVAP Purge Monitor 814
Sebring (All Engines) Inoperative OBD EVAP Purge Monitor 803
Sebring Convertible 2.4L Incorrect Vacuum Diagram, Purge Control Valve. Replace VECI Label 751
DODGE 
Breeze & Stratus Inoperative OBD EVAP Purge Monitor 803
Intrepid 2.7L & 3.2L Reflash PCM For EVAP Purge Monitor 814
FORD 
Contour Burr On End Of Accelerator Cable, Install Revised Cable 99V194000
MERCURY 
Mystique Burr On End Of Accelerator Cable, Install Revised Cable 99V194000
PONTIAC 
Bonneville 3.8L (VIN K) Faulty Spark Plug, PCM Reflash 98003
Bonneville 3.8L VECI Label Shows Reversed Vacuum Hose Connections To Canister Purge Solenoid SM-2926
OLDSMOBILE 
Eighty-Eight, LSS & Regency 3.8L (VIN K) Faulty Spark Plugs, PCM Reflash 98003
1999 
BUICK 
LeSabre 3.8L (Some Calif. LEV Models) False O2S DTC ML-GM663
LeSabre Replace Manual Valve/Link Assembly With Spring0Type Retainer 99V089000
LeSabre 3.8L VECI Label Shows Incorrect Vacuum Hose Connections To Canister Purge Solenoid SM-2926
CHEVROLET 
Impala, Lumina & Monte Carlo 3.8L VECI Label Shows Incorrect Vacuum Hose Connections To Canister Purge Solenoid SM-2927
CHRYSLER 
Concorde 2.7L & 3.2L Reflash PCM For EVAP Purge Monitor 814
DODGE 
Intrepid 2.7L & 3.2L Reflash PCM For EVAP Purge Monitor 814
FORD 
Taurus & Sable 3.0L Incorrect PCM Calibration 99E06
GEO 
Tracker Failure In Brake Light Actuating Switch. Replace Switch Assembly 99V273002
LINCOLN 
Continental 4.6L Damaged Crossover Hose During Fuel Rail Assembly 98V269000
Oldsmobile 88 Replace Manual Valve/Link Assembly With A Spring-Type Retainer 99V089000
PLYMOUTH 
Prowler 3.5L Replace Incorrect VECI Label 810
PONTIAC 
Bonneville 3.8L (Some Calif. LEV Models) False O2S DTC ML-GM663
Bonneville Replace Manual Valve/Link Assembly With A Spring-Type Retainer 99V089000
Bonneville 3.8L VECI Label Shows Reversed Vacuum Hose Connections To Canister Purge Solenoid SM-2926
2000 
BUICK 
Century & Regal Inspect Fuel Hose Fill Neck Clamp/Reposition & Tighten Clamp 00V160000
Park Avenue & Regal 3.8L SC Incorrect Spark Plugs ML-GM687
CADILLAC 
DeVille Throttle Linkage & Control 00V021000
DeVille, Eldorado & Seville 4.6L Faulty CKP Sensor ML-GM704
DeVille, Eldorado & Seville 4.6L DTC P0101 Is Set, But MAF Sensor Is Good & No Driveability Problem. Reprogram PCM Using Tech 2 Scan Tool 01-06-04-002A
CHEVROLET 
Impala & Lumina Inspect Fuel Hose Fill Neck Clamp/Reposition & Tighten Clamp 00V160000
Malibu Fuel Leak, Fuel Fill Tube Fitting Not Properly Secured 99V302000
CHRYSLER 
Cirrus Unpainted Fuel Tank Straps. Replace 00V067000
DODGE 
Neon Throttle Linkage & Control 00V194000
      Reflash PCM With Updated Calibration 833
      Replace Brake Booster Vacuum Hose 01V154000
      False Air Bag Code Due To Ignition Switch Being Cycled 2X In 10 Seconds, Causing Voltage Spike From LDP To Feed Back To Air Bag Module During Self-Check. Install Jumper Harness With Diode To Prevent False Code. 08-025-02
Stratus Unpainted Fuel Tank Straps. Replace 00V067000
FORD 
Contour (Bi-Fuel) Damaged Fuel Tank Filler Pipe Grommet 00V350000
Focus 2.0L Contaminated Fuel Delivery Module Filter 99E07
      Corroded Speed Control Cable, Does Not Return To Idle 99V346000
      A/T, Speed Control Core Too Long & Binds At WOT, Does Not Return To Idle 00V302000
Taurus Measure Spacing Between Brake & Throttle Accelerator Pedals, Adjust 02V266000
      DTC P0401, P0402, P1400 Or P1401 Set. Check For Tube Mounted EGR DPFE Sensor. If It Is. Replace With New Sensor P/N 2F1Z-9J460-AA 03-2-2
MERCURY 
Sable Incorrect Safety Certification Label, New Label 00V242000
      Measure Spacing Between Brake & Throttle Accelerator Pedals, Adjust 02V266000
      DTC P0401, P0402, P1400 Or P1401 Set. Check For Tube Mounted EGR DPFE Sensor. If It Is. Replace With New Sensor P/N 2F1Z-9J460-AA 03-2-2
PLYMOUTH 
Neon Cold Ambient Temp. Throttle Body Freeze. Replace & Relocate PCV System Tube 00V194000
      Reflash PCM With Updated Calibration 833
      Replace Brake Booster Vacuum Hose 01V154000
PONTIAC 
Bonneville & Grand Prix 3.8L SC Incorrect Spark Plugs ML-GM687
SATURN 
L-Series Permanently Seal Outlet Port Of OPR Valve 99V345000
      Failure Of Ignition Control Module. Replace Module & Spark Plugs. Update PCM Calibration 03V231000
S-Series Inspect Fuel Tank Vent Valve For Proper Weld. Replace 00V309000
      Inspect/Replace Brake Pedal Assembly 02V060
2001 
CHEVROLET 
Camaro V8 Engine Knocking. Replace Cut O-Ring Seal Between Oil Pump & Pick-Up Screen (Oil Aeration) 02-06-01-038
Corvette 5.7L (VIN S) Incorrect VECI Label DCS674
Corvette Engine Knocking. Replace Cut O-Ring Seal Between Oil Pump & Pick-Up Screen (Oil Aeration) 02-06-01-038
Impala Police/Taxi 3.8L MIL Illuminated, Poor Performance & Reduced Top Speed. Replace Catalytic Converter & Revised Brake Booster Hose 03-06-05-002
CHRYSLER 
Sebring Grounded CKP Sensor Harness, Repair & Reroute Sensor Harness 00V299002
      Fuel Return Hose Deterioration. Replace Hose 00V320002
PT Cruiser Check Abrasion Between Fuel Line & A/C Line Service Port, Install Clip 02V214
DODGE 
Neon False Air Bag Code Due To Ignition Switch Being Cycled 2X In 10 Seconds, Causing Voltage Spike From LDP To Feed Back To Air Bag Module During Self-Check. Install Jumper Harness With Diode To Prevent False Code. 08-025-02
Stratus Replace Brake Booster Vacuum Hose 01V154000
      Grounded CKP Sensor Harness, Repair & Reroute Sensor Harness 00V2999002
      Fuel Return Hose Deterioration. Replace Hose 00V320002
FORD 
Crown Victoria
Focus
Mustang		 DTC P0401, P0402, P1400 Or P1401 Set.
Check For Tube Mounted EGR DPFE Sensor.
If It Is, Replace With New Sensor P/N 2F1Z-9J460-AA.		 03-2-2
Taurus Measure Spacing Between Brake & Accelerator Pedals, Adjust 02V266000
      DTC P0401, P0402, P1400 Or P1401 Set.
Check For Tube Mounted EGR DPFE Sensor.
If It Is, Replace With New Sensor P/N 2F1Z-9J460-AA.		 03-2-2
LINCOLN 
Town Car DTC P0401, P0402, P1400 Or P1401 Set.
Check For Tube Mounted EGR DPFE Sensor.
If It Is, Replace With New Sensor P/N 2F1Z-9J460-AA.		 03-2-2
MERCURY 
Cougar
Grand Marquis		 DTC P0401, P0402, P1400 Or P1401 Set.
Check For Tube Mounted EGR DPFE Sensor.
If It Is, Replace With New Sensor P/N 2F1Z-9J460-AA.		 03-2-2
Sable Measure Spacing Between Brake & Accelerator Pedals, Adjust 02V266000
      DTC P0401, P0402, P1400 Or P1401 Set.
Check For Tube Mounted EGR DPFE Sensor.
If It Is, Replace With New Sensor P/N 2F1Z-9J460-AA.		 03-2-2
PLYMOUTH 
Neon Replace Brake Booster Vacuum Hose 01V154000
PONTIAC 
Firebird V8 Engine Knocking. Replace Cut O-Ring Seal Between Oil Pump & Pick-Up Screen (Oil Aeration) 02-06-01-038
SATURN 
L-Series Failure Of Ignition Module. Replace Module & Spark Plugs. Update PCM Calibration 03V231000
S-Series Inspect Fuel Tank Vent Valve For Proper Weld. Replace 00V309000
2002 
CHEVROLET 
Camaro V8 Engine Knocking. Replace Cut O-Ring Seal Between Oil Pump & Pick-Up Screen (Oil Aeration) 02-06-01-038
Impala Police/Taxi 3.8L MIL Illuminated, Poor Performance & Reduced Top Speed. Replace Catalytic Converter & Revised Brake Booster Hose 03-06-05-002
CHRYSLER 
Neon False Air Bag Code Due To Ignition Switch Being Cycled 2X In 10 Seconds, Causing Voltage Spike From LDP To Feed Back To Air Bag Module During Self-Check. Install Jumper Harness With Diode To Prevent False Code. 08-025-02
PT Cruiser Install Secondary Seal Over Fuel Pump Module 02V215
FORD 
Crown Victoria
Focus		 DTC P0401, P0402, P1400 Or P1401 Set.
Check For Tube Mounted EGR DPFE Sensor.
If It Is, Replace With New Sensor P/N 2F1Z-9J460-AA.		 03-2-2
Focus SVT Throttle Does Not Return To Closed Position. Replace Throttle Body 02V117000
Mustang DTC P0401, P0402, P1400 Or P1401 Set.
Check For Tube Mounted EGR DPFE Sensor.
If It Is, Replace With New Sensor P/N 2F1Z-9J460-AA.		 03-2-2
Taurus Measure Spacing Between Brake & Accelerator Pedals, Adjust 02V266000
      DTC P0401, P0402, P1400 Or P1401 Set.
Check For Tube Mounted EGR DPFE Sensor.
If It Is, Replace With New Sensor P/N 2F1Z-9J460-AA.		 03-2-2
LINCOLN 
Town Car DTC P0401, P0402, P1400 Or P1401 Set.
Check For Tube Mounted EGR DPFE Sensor.
If It Is, Replace With New Sensor P/N 2F1Z-9J460-AA.		 03-2-2
MERCURY 
Cougar
Grand Marquis		 DTC P0401, P0402, P1400 Or P1401 Set.
Check For Tube Mounted EGR DPFE Sensor.
If It Is, Replace With New Sensor P/N 2F1Z-9J460-AA.		 03-2-2
Sable Measure Spacing Between Brake & Accelerator Pedals. Adjust 02V266000
      DTC P0401, P0402, P1400 Or P1401 Set.
Check For Tube Mounted EGR DPFE Sensor.
If It Is, Replace With New Sensor P/N 2F1Z-9J460-AA.		 03-2-2
PONTIAC 
Firebird V8 Engine Knocking. Replace Cut O-Ring Seal Between Oil Pump & Pick-Up Screen (Oil Aeration) 02-06-01-038
SATURN 
L-Series Failure Of Ignition Module. Replace Module & Spark Plugs. Update PCM Calibration 03V231000
2003 
BUICK 
Century Replace Faulty Delphi Fuel Pressure Regulator Sold After January 9, 2007. Delphi To Notify Owners Or Contact Delphi At 877-411-8770. 07E021000
CADILLAC 
DeVille & Seville Excessive Vacuum Pressure Applied To EVAP System During Self-Test. Replace Fuel Tank Pressure Sensor 03V238000
CHEVROLET 
Camaro V8 Engine Knocking. Replace Cut O-Ring Seal Between Oil Pump & Pick-Up Screen (Oil Aeration) 02-06-01-038
Impala
Malibu		 Replace Faulty Delphi Fuel Pressure Regulator Sold After January 9, 2007. Delphi To Notify Owners Or Contact Delphi At 877-411-8770. 07E021000
CHRYSLER 
Concorde
300M		 A defect in the camshaft position sensor software could ultimately cause damage to the catalytic converters. Chrysler will update the Powertrain Control Module (PCM) calibration to prevent damage to the catalytic converters. 2009-01-E or J18
Concorde
300M		 The catalytic converters on these vehicles may become damaged from continued operation in "limp-in" mode following a camshaft position sensor fault. Chrysler dealers will reprogram the Powertrain Control Module (PCM). 2009-01a-E (J18)
PT Cruiser (M/T) DMF Assembly Can Unseat/Become Lodged Between Flywheel & Clutch Disc. Replace Assembly 03V076000
DODGE 
Viper Engine Stalls. Fuel Pump Fuse Opens Due To Harness Chaffing. Install Protective Wrap On Fuel Pump Harness & Cover Edge Of Heat Shield. 03V292000
FORD 
Focus Some vehicles may exhibit incomplete inspection/maintenance (I/M) readiness status during state inspection. Reprogram the powertrain control module (PCM) to the latest calibration using WDS release B42.2 and higher. TSB06-7-5
Thunderbird Water Or Oil Entering Ignition Coil Cover & Spark Plug Bore Causing Misfire. Replace Ignition Coils As Needed & Valve Cover Gaskets. Ford Extending Warranty To 10 Yrs. Or 100, 000 Miles Whichever Comes First 07M07 & 07N09
LINCOLN 
LS PCV Hose Becomes Loose And Disconnects. Ford Extending Warranty On PCV Hose Assembly To 10 Yrs. Or 100, 000 Miles Whichever Comes First 08N01
      Water Or Oil Entering Ignition Coil Cover & Spark Plug Bore Causing Misfire. Replace Ignition Coils As Needed & Valve Cover Gaskets. Ford Extending Warranty To 10 Yrs. Or 100, 000 Miles Whichever Comes First 07M07 & 07N09
OLDSMOBILE 
Aurora Excessive Vacuum Pressure Applied To EVAP System During Self-Test. Replace Fuel Tank Pressure Sensor 03V238000
PONTIAC 
Bonneville SC Excessive Vacuum Pressure Applied To EVAP System During Self-Test. Replace Fuel Tank Pressure Sensor 03V238000
Firebird V8 Engine Knocking. Replace Cut O-Ring Seal Between Oil Pump & Pick-Up Screen (Oil Aeration) 02-06-01-038
SATURN 
L-Series Failure Of Ignition Module. Replace Module & Spark Plugs. Update PCM Calibration 03V231000
2004 
BUICK 
Century Replace Faulty Delphi Fuel Pressure Regulator Sold After January 9, 2007. Delphi To Notify Owners Or Contact Delphi At 877-411-8770. 07E021000
Rendezvous Faulty Fuel Tank 03V454000
      Faulty Ignition Relay 05V157000
CADILLAC 
CTS Faulty Airbag Sensing & Diagnostic Module; Air Bag Deployment When Ignition Is Turned ON 05V024000
      Fuel Feed Jumper Pipe Built Out Of Specification. Replace Pipe. ML-MW067
Deville & Seville 4.6L Engines, AIR Disabled From Previous Service Procedure Or PCM Reprogramming/Replacement. Dealer To Reprogram PCM And Verify AIR Operation 08206 ML-MW317 or 3625
SRX Faulty Accelerator Pedal Spring. Replace Accelerator Pedal Assembly 05V046000
CHRYSLER 
Concorde
300M		 A defect in the camshaft position sensor software could ultimately cause damage to the catalytic converters. Chrysler will update the Powertrain Control Module (PCM) calibration to prevent damage to the catalytic converters. 2009-01-E or J18
Concorde
300M		 The catalytic converters on these vehicles may become damaged from continued operation in "limp-in" mode following a camshaft position sensor fault. Chrysler dealers will reprogram the Powertrain Control Module (PCM). 2009-01a-E (J18)
LINCOLN 
LS PCV Hose Becomes Loose And Disconnects. Ford Extending Warranty On PCV Hose Assembly To 10 Yrs. Or 100, 000 Miles Whichever Comes First 08N01
PONTIAC 
Bonneville 4.6L Engines, AIR Disabled From Previous Service Procedure Or PCM Reprogramming/Replacement. Dealer To Reprogram PCM And Verify AIR Operation 08206 ML-MW317 or 3625
Grand Am Faulty/Leaking Fuel Tank 04V301000
SATURN 
Ion Fuel Filter Premature Corrosion. Replace Filter Assembly 04V003000
Ion (Supercharged) Fuel Feed Pipe Could Crack & Leak Near Fuel Rail. Replace Fuel Feed Pipe. 04V281000
2005 
BUICK 
Century Replace Faulty Delphi Fuel Pressure Regulator Sold After January 9, 2007. Delphi To Notify Owners Or Contact Delphi At 877-411-8770. 07E021000
LaCrosse Damaged PCM Integrated Circuit. Replace PCM ML-MW106
CADILLAC 
CTS Fuel Feed Jumper Pipe Built Out Of Specification. Replace Pipe. ML-MW067
Deville & Seville 4.6L Engines, AIR Disabled From Previous Service Procedure Or PCM Reprogramming/Replacement. Dealer To Reprogram PCM And Verify AIR Operation 08206 ML-MW317 or 3625
CHEVROLET 
Classic Damaged PCM Integrated Circuit. Replace PCM ML-MW106
Corvette Faulty Or Broken Fuel Cap. GM Has Extended Fuel Cap Warranty To 10 Yrs. Or 120, 000 Miles Whichever Comes First 07053 ML-MW295 or 2776
Impala Replace Faulty Delphi Fuel Pressure Regulator Sold After January 9, 2007. Delphi To Notify Owners Or Contact Delphi At 877-411-8770. 07E021000
Malibu Damaged PCM Integrated Circuit. Replace PCM ML-MW106
      Faulty Or Broken Fuel Cap. GM Has Extended Fuel Cap Warranty To 10 Yrs. Or 120, 000 Miles Whichever Comes First ML-MW209 or EPA 2905
Monte Carlo Replace Faulty Delphi Fuel Pressure Regulator Sold After January 9, 2007. Delphi To Notify Owners Or Contact Delphi At 877-411-8770. 07E021000
CHRYSLER 
Magnum Loose Battery Cable Fastener At Bulkhead Improperly Tightened, Causing Instrument Panel Fire. Tighten Bulkhead Stud Battery Cable Fastener 04V334000
Neon SRT-4 OBD Fuel System Monitor Disabled. Reprogram PCM 2002-21-E & D46
PT Cruiser OBD Fuel System Monitor Disabled. Reprogram PCM 2002-21-E & D46
300 Loose Battery Cable Fastener At Bulkhead Improperly Tightened, Causing Instrument Panel Fire. Tighten Bulkhead Stud Battery Cable Fastener 04V334000
      Wrong PCM Calibration (European). Replace PCM With Correct U.S. Calibration 2004-13
      Typo Error On Spark Plug Specification On VECI Label. Replace VECI Label 2004-17 & 2004-17-E
DODGE 
Caravan Oil Filler Cap Does Not Confirm To EPA Guidance Letter. Oil Viscosity Not Displayed On Cap. Replace Oil Filler Cap 2004-8
Magnum Typo Error On Spark Plug Specification On VECI Label. Replace VECI Label 2004-17 & 2004-17-E
FORD 
Crown Victoria Incorrect Design Aftermarket Purolator Fuel Filter (Purolator P/N F65277). Contact UFI Filters USA At 800-230-5876 06E056000
Thunderbird Faulty/Leaking Fuel Tank. Replace Fuel Tank 05V113000
LINCOLN 
LS Faulty/Leaking Fuel Tank. Replace Fuel Tank 05V113000
      PCV Hose Becomes Loose And Disconnects. Ford Extending Warranty On PCV Hose Assembly To 10 Yrs. Or 100, 000 Miles Whichever Comes First 08N01
PONTIAC 
Aveo Faulty Or Broken Fuel Cap. GM Has Extended Fuel Cap Warranty To 10 Yrs. Or 120, 000 Miles Whichever Comes First 08241 ML-MW315 or 3593
Bonneville 4.6L Engines, AIR Disabled From Previous Service Procedure Or PCM Reprogramming/Replacement. Dealer To Reprogram PCM And Verify AIR Operation 08206 ML-MW317 or 3625
Grand Prix Damaged PCM Integrated Circuit. Replace PCM ML-MW106
G6 Damaged PCM Integrated Circuit. Replace PCM ML-MW106
GTO Faulty Or Broken Fuel Cap. GM Has Extended Fuel Cap Warranty To 10 Yrs. Or 120, 000 Miles Whichever Comes First 07053 ML-MW295 or 2776
Sunfire Damaged PCM Integrated Circuit. Replace PCM ML-MW106
2006 
BUICK 
    NOTE  : Certain 2006 GM and Isuzu vehicles equipped with 2.2L, 4.2L and 4.6L engines and Secondary Air Injection Reaction (SAIR) systems have a condition in which the SAIR system and diagnostics are disabled without MIL illumination because of a short in the SAIR pump or valve relay driver circuit. 10149
CADILLAC 
CTS Fuel Delivery Problem. Reprogram ECM With New Software. 06V020000
DTS Certain 2006 GM and Isuzu vehicles equipped with 2.2L, 4.2L and 4.6L engines and Secondary Air Injection Reaction (SAIR) systems have a condition in which the SAIR system and diagnostics are disabled without MIL illumination because of a short in the SAIR pump or valve relay driver circuit. 10149
STS AWD ETC Not Enabled. Reprogram ECM. 06V007000
STS Fuel Delivery Problem. Reprogram ECM With New Software. 06V020000
CHEVROLET 
Cobalt Replace Faulty Injectors ML-MW206 or 2823
Cobalt Certain 2006 GM and Isuzu vehicles equipped with 2.2L, 4.2L and 4.6L engines and Secondary Air Injection Reaction (SAIR) systems have a condition in which the SAIR system and diagnostics are disabled without MIL illumination because of a short in the SAIR pump or valve relay driver circuit. 10149
CHRYSLER 
300 Pre-Catalysts Foil Substrate Fracture & Separation Due To Thermal Cycling Causing Exhaust Emissions To Exceed Standards & MIL to Illuminate. Dealer To Replace & Reprogram PCM. 2006-27-E (F47) or 2806
DODGE 
Charger
Magnum		 Pre-Catalysts Foil Substrate Fracture & Separation Due To Thermal Cycling Causing Exhaust Emissions To Exceed Standards & MIL to Illuminate. Dealer To Replace & Reprogram PCM. 2006-27-E (F47) or 2806
Viper VECI Label Does Not Display Proper Classification For 2 Oxidation Catalyst (2OC). Replace VECI Label EDIR-2006-5 F07
FORD 
Five Hundred
Focus		 Incorrect Design Aftermarket Purolator Fuel Filter (Purolator P/N F65277). Contact UFI Filters USA At 800-230-5876 06E056000
MERCURY 
Grand Marquis Faulty Aftermarket Fuel Filter (Purolator P/N F65277). Replace Fuel Filter. Contact UFI Filters USA At 800-230-5876 06E056000
SATURN 
ION Certain 2006 GM and Isuzu vehicles equipped with 2.2L, 4.2L and 4.6L engines and Secondary Air Injection Reaction (SAIR) systems have a condition in which the SAIR system and diagnostics are disabled without MIL illumination because of a short in the SAIR pump or valve relay driver circuit. 10149
2007 
BUICK 
LaCrosse Replace Fuel Tank With Missing Adhesive Layer Bonding The Barrier Layer To Outer Shell 06V419000
CHEVROLET 
Aveo Replace Underhood Fuse Block & Install Redesigned Engine Compartment Fuel Line 06V398000
Cobalt Incorrect TCM Calibration Installed In Some Vehicles, Causing TCC Hunting, Engine Speed Variation & Harsh Shifts. Dealer To Install Correct TCM Calibration ML-MW22007153 or EPA 2975
Impala Replace Fuel Tank With Missing Adhesive Layer Bonding The Barrier Layer To Outer Shell 06V419000
CHRYSLER 
Sebring Vehicles With A/T TIPM Stuck In One Forward Gear Under Certain Start-Up Sequence. Dealer To Reprogram TIPM On Affected Vehicles 2007-15-E (G23) or 2960
DODGE 
Caliber OBD Thermostat Monitor F29
FORD 
Crown Victoria
Five Hundred
Focus		 Faulty Aftermarket Fuel Filter (Purolator P/N F65277). Replace Fuel Filter. Contact UFI Filters USA At 800-230-5876 06E056000
PONTIAC 
Grand Prix Replace Fuel Tank With Missing Adhesive Layer Bonding The Barrier Layer To Outer Shell 06V419000
SATURN 
Aura Hybrid Voltage Imbalance Within Hybrid Batteries Causing MIL Illumination And Disabling Of Hybrid Function. Dealer To Replace Hybrid Cassettes Within Battery Assembly 07318-ML-MW271
2008 
CHRYSLER 
Avenger AWD Improperly Manufactured Fuel Tank Straps Could Separate & Cause Fuel Tank To Loosen & Leak 07V426000
Avenger 2.4L Engines, Inspect Left Radiator Cooling Fan Motor Connector For Coolant Contamination Or Damage 07V473000
      Wrong VECI Affixed To Early MY 2008 Vehicles. Dealer To Replace On Affected Vehicles 2007-6-E (G06) or 2900
      Vehicles With A/T TIPM Stuck In One Forward Gear Under Certain Start-Up Sequence. Dealer To Reprogram TIPM On Affected Vehicles 2007-15-E (G23) or 2960
Sebring 2.4L Engines, Inspect Left Radiator Cooling Fan Motor Connector For Coolant Contamination Or Damage 07V473000
      Vehicles With A/T TIPM Stuck In One Forward Gear Under Certain Start-Up Sequence. Dealer To Reprogram TIPM On Affected Vehicles 2007-15-E (G23) or 2960
DODGE 
Caliber SRT4 PCM Programmed With Software That Disabled 3 Engine Diagnostic Monitors. Dealer To Reprogram PCM 2008-37-E-H32 or 3614
SATURN 
Aura Hybrid Voltage Imbalance Within Hybrid Batteries Causing MIL Illumination And Disabling Of Hybrid Function. Dealer To Replace Hybrid Cassettes Within Battery Assembly 07318-ML-MW271
2009 
CHRYSLER 
Sebring PCM Manufactured With Adhesive That Could Cause Printed Circuit Board To Break Causing Engine Stall. Dealer To Replace And Reprogram PCM 2008-38-E-H33 or 3615
Sebring
Town & Country		 On certain vehicles equipped with 2.7L and 4.0L engines the Positive Crankcase Ventilation (PCV) valve may have an incorrect flow characteristic. Two shipments of PCV valves from the Tier 2 supplier consisted of mixed stock. Chrysler will conduct a voluntary emissions recall to inspect the potentially affected vehicles and to replace any incorrect PCV valves found. 209-04E J03
DODGE 
Avenger
Caliber		 PCM Manufactured With Adhesive That Could Cause Printed Circuit Board To Break Causing Engine Stall. Dealer To Replace And Reprogram PCM 2008-38-E-H33 or 3615
Nitro
Avenger
Grand Caravan		 On certain vehicles equipped with 2.7L and 4.0L engines the Positive Crankcase Ventilation (PCV) valve may have an incorrect flow characteristic. Two shipments of PCV valves from the Tier 2 supplier consisted of mixed stock. Chrysler will conduct a voluntary emissions recall to inspect the potentially affected vehicles and to replace any incorrect PCV valves found. 209-04E J03
Caliber SRT4 The original Vehicle Emissions Control Label (VECI) does not include the required identifier for vehicles built with a turbocharged engine. Chrysler is sending corrected VECI labels to vehicle owners to be applied to the affected vehicles. 2008-44E or H43
2010 
CADILLAC 
SRX GM has found that certain vehicles equipped with a 2.8L turbo-charged engine were built with an incorrect Vehicle Emissions Control Information (VECI) label. The label misidentifies the emissions test group. 10022
CHRYSLER 
300 The Customer may be failed or rejected at a state I/M test station because: a. P0456 - Evap Small Leak Monitor has failed b. Evaporative Leak Detection Monitor is not "Ready" c. P1115 - General Temperature Sensor Rationality has failed
Reprogram the PCM with the latest software.		 18-008-10 REV. A
DODGE 
Challenger, Charger The Customer may be failed or rejected at a state I/M test station because: a. P0456 - Evap Small Leak Monitor has failed b. Evaporative Leak Detection Monitor is not "Ready" c. P1115 - General Temperature Sensor Rationality has failed
Reprogram the PCM with the latest software.		 18-008-10 REV. A
scientia non olet · About LEMON Manuals