Tightening Torque Specifications
WARNING: This page is about a different car, the 2010 Ford Pickup, 2010 Ford F550 Super Duty, 2010 Ford F450 Super Duty, and 2010 Ford Cab & Chassis. However, it is still accessible from the selected car via links, so may be relevant.
TIGHTENING TORQUE SPECIFICATIONS
| Description | Nm | lb-ft | lb-in | ||
|---|---|---|---|---|---|
| A/C compressor bolts | 25 | 18 | - | ||
| A/C compressor nuts | 20 | - | 177 | ||
| Accessory drive belt idler pulley bolt | 25 | 18 | - | ||
| Accessory drive belt tensioner bolt | 25 | 18 | - | ||
| Balance shaft bearing cap bolts(1) | - | - | - | ||
| Camshaft bearing cap bolts(1) | - | - | - | ||
| Camshaft Position (CMP) sensor bolt | 10 | - | 89 | ||
| Camshaft sprocket bolt(1) | - | - | - | ||
| Connecting rod bolts(1) | - | - | - | ||
| Coolant pump bolts | 25 | 18 | - | ||
| Coolant pump pulley bolts | 25 | 18 | - | ||
| Coolant tube stud bolt | 10 | - | 89 | ||
| Cooling fan clutch hub-to-cooalnt pump nut | 133 | 98 | - | ||
| Crankshaft pulley bolt(1) | - | - | - | ||
| Crankshaft main bearing bolts (cross-mounted)(1) | - | - | - | ||
| Crankshaft main bearing bolts (vertical)(1) | - | - | - | ||
| Crankshaft Position (CKP) sensor bolt | 10 | - | 89 | ||
| Crankshaft rear seal retainer plate bolts(1) | - | - | - | ||
| Cylinder block drain plug | 24 | 18 | - | ||
| Cylinder head bolts(1) | - | - | - | ||
| Cylinder Head Temperature (CHT) | 10 | - | 89 | ||
| Engine coolant crossover assembly bolts | 10 | - | 89 | ||
| Engine front cover bolts(1) | - | - | - | ||
| Engine Oil Pressure (EOP) switch | 18 | - | 159 | ||
| Engine support insulator bracket bolts(1) | - | - | - | ||
| Engine support insulator-to-crossmember nuts - RH | 115 | 85 | - | ||
| Engine support insulator-to-crossmember nuts - LH | 200 | 148 | - | ||
| Engine support insulator through bolt | 350 | 258 | - | ||
| Engine support insulator studs | 80 | 59 | - | ||
| Engine wiring harness ground strap nut | 10 | - | 89 | ||
| Exhaust manifold flange nuts | 40 | 30 | - | ||
| Exhaust manifold heat shield bolts | 14 | - | 124 | ||
| Exhaust manifold nuts(1) | - | - | - | ||
| Exhaust manifold-to-catalytic converter nuts | 40 | 30 | - | ||
| Exhaust manifold-to-cylinder head studs | 12 | - | 106 | ||
| Exhaust Y-pipe flange nuts | 40 | 30 | - | ||
| Flexplate bolts(1) | - | - | - | ||
| Flexplate inspection cover bolts | 34 | 25 | - | ||
| Flywheel bolts(1) | - | - | - | ||
| Front oil level indicator tube bolt | 25 | 18 | - | ||
| Fuel rail bolts | 10 | - | 89 | ||
| Fuel tube bracket nut | 12 | - | 106 | ||
| Ground strap stud bolt | 10 | - | 89 | ||
| Ignition coil bolt | 6 | - | 53 | ||
| Intake manifold bolts(1) | - | - | - | ||
| Intake Manifold Runner Control (IMRC) | 10 | - | 89 | ||
| Knock Sensor (KS) | 20 | - | 177 | ||
| Oil cooler | 58 | 43 | - | ||
| Oil filter | 16 | - | 142 | ||
| Oil filter adapter bolts | 25 | 18 | - | ||
| Oil filter adapter nut | 48 | 35 | - | ||
| Oil filter adapter stud | 12 | - | 106 | ||
| Oil pan bolts(1) | - | - | - | ||
| Oil pan drain plug | 14 | - | 124 | ||
| Oil pump bolts | 10 | - | 89 | ||
| Oil pump screen and pickup tube spacer | 25 | 18 | - | ||
| Oil pump screen and pickup tube-to-oil pump bolts | 10 | - | 89 | ||
| Oil pump screen and pickup tube-to-spacer bolt | 25 | 18 | - | ||
| Power steering pump bolts | 25 | 18 | - | ||
| Radio ignition interference capacitor nut | 25 | 18 | - | ||
| Rear oil level indicator tube bolt | 10 | - | 89 | ||
| Rear transmission insulator nuts | 115 | 85 | - | ||
| Skid plate bolts | 24 | 18 | - | ||
| Spark plugs | 12 | - | 106 | ||
| Throttle Body (TB) spacer-to-intake manifold bolts(1) | - | - | - | ||
| TB bolts(1) | - | - | - | ||
| Timing chain guide bolts | 10 | - | 89 | ||
| Timing chain hydraulic tensioner bolts | 25 | 18 | - | ||
| Torque converter-to-flexplate nuts | 35 | 26 | - | ||
| Transmission cooler tube support bracket and the starter wiring harness support bracket nut | 25 | 18 | - | ||
| Transmission fluid filler/level indicator tube bolt | 10 | - | 89 | ||
| Transmission mount-to-crossmember nuts | 115 | 85 | - | ||
| Transmission-to-engine bolts | 48 | 35 | - | ||
| Transmission wiring harness support bracket bolt | 10 | - | 89 | ||
| Valve cover bolts(1) | - | - | - | ||
|
|||||