LEMON Manuals: Even more car manuals for everyone
Home >> Mercedes Benz >> 2021 >> S63 AMG 2D Convertible >> Repair and Diagnosis >> Brakes >> Traction Control >> Brakes - Hydraulic & Mechanical System - 217 Chassis (1 Of 2) >> Testing & Repair >> Removing, Checking And Installing Rear Axle Brake Pads - AR42.10-P-1700LF

Removing, Checking And Installing Rear Axle Brake Pads - AR42.10-P-1700LF

Model 217, 222 

G15347965Courtesy of MERCEDES-BENZ USA

Shown on MODEL 222 - right side of vehicle 

G15347966Courtesy of MERCEDES-BENZ USA
WARNING Risk of injury.  Skin or eye injuries may result when handling hot or glowing objects. Wear protective gloves, protective clothing and safety glasses, if necessary. AS00.00-Z-0002-01A
CAUTION Risk of poisoning  from swallowing brake fluid. Risk of injury  from skin and eye contact with brake fluid Only pour brake fluid into suitable and appropriately marked containers. Wear protective clothing and eye protection when handling brake fluid. AS42.50-Z-0001-01A 
Notice Brake fluid notes   AH42.50-P-0001-01A 
Notice Notes on self-locking nuts and bolts   AH00.00-P-0001-01KOA
Notice Notes on repairs to brake system   AH42.00-P-0003-01A 
  Notes on installing brake wear indicator contact sensors   AH42.10-P-0003-01CW 
REMOVINGINSTALLING Remove/install     
1 Move brake pads (10) of the rear axle into assembly position NOTES Do not depress the service brake during "Move to assembly position".
Otherwise, the spindle in the brake caliper (3) can be damaged.
IMPORTANT The engine hood must be closed.
AR42.10-P-1700-02W 
2 Switch off ignition and remove transmitter key    
3 Remove cover over brake fluid expansion reservoir    
CLEAN Clean     
4 Clean area surrounding the cap of the brake fluid expansion reservoir Assembly cleaner *BR00.45-Z-1028-04A 
5 Unscrew the cap on the brake fluid expansion reservoir and suction off some brake fluid IMPORTANT In order to prevent the brake fluid expansion reservoir overflowing when pressing back the brake pistons.  
6 Detach corresponding complete wheel   AR40.10-P-1102A
7 Disconnect right rear brake wear sensor electrical connector (S10/4x1) from right rear brake wear sensor (S10/4) When removing brake linings (10) on right side of vehicle  
8 Detach electrical connection from left electric parking brake actuator motor (M76/1) or right electric parking brake actuator motor (M76/2)    
9 Remove bolt (1) from lower guide pin (5) IMPORTANT Counterhold lower guide pin (5) while doing so.  
    TORQUE SPECIFICATION Guide pin to brake caliper support or bolt for guide pin to brake caliper *BA42.10-P-1004-12J 
10 Swivel brake caliper (3) upwards IMPORTANT Do not detach brake hose (6).
INSTALLATION IMPORTANT Guide the right rear brake wear sensor (S10/4) through the opening of the brake caliper (3).
 
11 Remove brakepad (10) from brake caliper support (2) INSTALLATION IMPORTANT Only sets of brake linings (10) approved by Mercedes-Benz may be installed. Do not apply brake paste or lubricants to the brake pads (10) and brake calipers (3)!  
12 Pull right rear brake lining wear sensor (S10/4) out of brake lining (10) When removing brake linings (10) on right side of vehicle
INSTALLATION IMPORTANT Replace defective right rear brake lining wear sensor (S10/4).
 
13 Remove spring steel sheets (11) from brake caliper support (2)    
  Checking, measuring     
14 Check condition of brake linings (10)    
REFER TO MAINTENANCE   Model 217 AP42.10-P-4252C
REFER TO MAINTENANCE   Model 222
If necessary:

Replace brake linings (10).
AP42.10-P-4252HA
15 Check condition of brake disk (9) and gauge degree of wear    
REFER TO MAINTENANCE   Model 217 with code B07 (AMG - ceramic brake system) AP42.10-P-4258CC
REFER TO MAINTENANCE   Model 217 except code B07 (AMG - ceramic brake system) AP42.10-P-4258C
REFER TO MAINTENANCE   Model 222 with code B07 (AMG - ceramic brake system) AP42.10-P-4258HC
REFER TO MAINTENANCE   Model 222 except code B07 (AMG - ceramic brake system)
If necessary:

Replace brake disk (9).
AP42.10-P-4258HA
      AR42.10-P-0220LF 
16 Check brake caliper (3) and dust boot (13) on brake piston for damage If damage is present:

Replace brake caliper (3).
AR42.10-P-0080LF 
17 Check boots (12) for damage and correct seat If damage is present:

Replace brake caliper support (2).
AR42.10-P-0080LF 
18 Check guide pin (5) for ease of movement Replace brake caliper support (2) if damaged, see:

Replace brake caliper (3).
AR42.10-P-0080LF 
19 Press back brake piston using pusher tool (01) SPECIAL TOOL Resetting device
If the brake piston is difficult to move:

Replace brake caliper (3).
Fig 1
      AR42.10-P-0080LF 
CLEAN Clean     
20 Clean contact surfaces of brake linings (10) or brake caliper (3) and on brake caliper support (2) NOTES Do not use sharp-edged or pointed objects. The dust boots (13) can otherwise be damaged.  
    Assembly cleaner *BR00.45-Z-1028-04A 
21 Install in the reverse order    
DANGER Risk of accident  when commissioning the vehicle due to a lack of braking effect when the service brake is operated for the first time after repair work. Before starting the engine, actuate brake pedal several times until pressure is built up and maintained in the brake system. AS42.50-Z-0002-01A 
22 Depress brake pedal several times until brake pads (10) rest against brake disks (9)    
INSPECT Check     
23 Check fluid level in brake fluid expansion reservoir    
REFER TO MAINTENANCE     AP42.10-P-4210HA
24 Carry out brake test on the test stand    
REFER TO MAINTENANCE     AP42.00-P-4290BA
REAR AXLE BRAKE CALIPER

Number Designation Model 217 Model 222
BA42.10-P-1004-12J Guide pin to brake caliper support or bolt for guide pin to brake caliper Nm 35 35
Fig 1: Identifying Resetting Device (000 589 52 43 00)
G11128859Courtesy of MERCEDES-BENZ USA
REPAIR MATERIALS

Number Designation Order number
BR00.45-Z-1028-04A Assembly cleaner A 000 986 56 01