LEMON Manuals: Even more car manuals for everyone
Home >> Mercedes Benz >> 2021 >> S580 >> Repair and Diagnosis >> Suspension >> Front Suspension >> Front Axle -- 223 Chassis >> Testing & Repair >> Remove/Install Front Axle Steering Knuckle >> Remove/Install Front Axle Steering Knuckle - AR33.25-P-0400SG

Remove/Install Front Axle Steering Knuckle - AR33.25-P-0400SG

Model 223 

with code Z07 (B7 armoring on special protection version) 

MODIFICATION NOTES

02.04.2021 Nut, torsion bar linkage to steering knuckle Model 223 with code Z07 (B7 armoring for special protection version) BA32.20-P-1002-02O
06.09.2021 Work procedure changed.    
Fig 1: Front Axle Steering Knuckle Components Location - Model 223 With Code Z07
G16191055Courtesy of MERCEDES-BENZ USA
CAUTION Risk of injury  caused by scraping or cutting body parts on sharp vehicle parts Always wear protective gloves when working on or near sharp and non-deburred vehicle parts.
Deburr repair panels.
AS00.00-Z-0017-01A
Notice  Notes on self-locking nuts and bolts   AH00.00-P-0001-01KOA
Notice  Notes on threaded connections fastened using a tightening angle-based tightening process   AH00.00-P-0020-01A
Notice  Notes on air suspension   AH32.22-P-1000-01T
  Notes on safety-relevant components   AH00.00-Z-0019-01A
  Notes on repair work on suspension components   AH00.00-P-0100-01A
REMOVINGINSTALLING Remove/install     
1 Remove hub cover (1) at wheel hub. If the hub cover (1) cannot be removed:

Remove front wheel, remove hub cover (1) and reattach front wheel.
AR40.10-P-1102A
2 Loosen nut of front axle shaft at wheel hub. IMPORTANT The vehicle must be standing on its front wheels for this.
TORQUE SPECIFICATION Nut, front axle shaft to wheel hub
*BA33.30-P-1002-02K 
3 Remove corresponding front wheel.   AR40.10-P-1102A
4 Remove nut of front axle shaft at wheel hub. INSTALLATION IMPORTANT : Replace nut.
Tighten nut slightly by hand.
 
5 Reduce pneumatic pressure of suspension struts using diagnostic system.    
REFER TO SELF-DIAGNOSTIC SYSTEMS   NOTES
The complete wheels must not touch the ground.
Otherwise the suspension struts may suffer initial damage and malfunction at a later stage.
AD00.00-P-2000-06FR
6 Remove brake disk.   AR42.10-P-0230S
7 Remove brake cover plate (2). TORQUE SPECIFICATION Bolt brake cover plate on steering knuckle *BA42.10-P-1002-06I 
8 Disconnect electrical connector from rotational speed sensor and remove rotational speed sensor. TORQUE SPECIFICATION Bolt, rpm sensor to steering knuckle *BA42.30-P-1001-01K 
9 Remove line bracket (3) from steering knuckle (4) and hang to one side with electric lines. TORQUE SPECIFICATION Bolt, cable holder to steering knuckle *BA42.30-P-1002-01K 
10 Remove tie rod joint from steering knuckle (4).   AR46.40-P-0211S
11 Remove tension strut from steering knuckle (4).   AR33.15-P-0160SG 
12 Remove upper transverse control arm from steering knuckle (4). NOTES
The ball head must be counterheld and an impact wrench/driver must not be used.
Otherwise the ball head or steering knuckle (4) will be damaged.
TORQUE SPECIFICATION Nut, steering knuckle to transverse control arm
*BA33.20-P-1006-01T 
13 Detach torsion bar linkage from steering knuckle (4). TORQUE SPECIFICATION Nut, torsion bar linkage to steering knuckle *BA32.20-P-1002-02O 
14 Remove spring link from steering knuckle (4).   AR33.15-P-0170SG 
15 Remove steering knuckle (4).    
16 Install a new wheel bearing into steering knuckle (4). If steering knuckle (4) is replaced. AR33.20-P-0302SG 
17 Install in the reverse order    
FRONT AXLE TORSION BAR

Number Designation Model 223 with code Z07 (B7 armoring on special protection version) except code 490 (Electrohydraulic suspension)
BA32.20-P-1002-02O Nut, torsion bar linkage to steering knuckle Nm 100
WHEEL CONTROL, HUB

Number Designation Model 223 with code Z07 (B7 armoring on special protection version)
BA33.20-P-1006-01T Nut, steering knuckle to transverse control arm Stage 1 Nm 50
Stage 2 ∠° 45
FRONT AXLE SHAFT

Number Designation Model 223 with code M005 (Vehicles with 4MATIC/all-wheel drive) with code Z07 (B7 armoring on special protection version)
BA33.30-P-1002-02K Nut, front axle shaft to wheel hub Stage 1 Nm 250
Stage 2 ∠° loosen
Stage 3 Nm 130
Stage 4 ∠° 45
BRAKE DISKS, BRAKE COVER PLATE

Number Designation Model 223 with code Z07 (B7 armoring on special protection version)
BA42.10-P-1002-06I Bolt brake cover plate on steering knuckle Nm 14
FRONT AXLE RPM SENSOR

Number Designation Model 223
BA42.30-P-1001-01K Bolt, rpm sensor to steering knuckle M6 Nm 8
FRONT AXLE RPM SENSOR

Number Designation Model 223
BA42.30-P-1002-01K Bolt, cable holder to steering knuckle Nm 8