Remove/Install Headlamp Unit - AR82.10-P-4730LC
Model 217
Shown on right front lamp unit (9)
| Information on preventing damage to electronic components due to electrostatic discharge | AH54.00-P-0001-01A | ||
| Remove/install | |||
| 1 | Remove front bumper | AR88.20-P-2000LC | |
| 2 | Remove engine compartment paneling (1, 2) | ||
| 3 | Remove engine air intake duct (3) | When removing right front lamp unit (9). | |
| 4 | Unclip coolant line (4) from washer fluid reservoir (5) | When removing right front lamp unit (9). | |
| 5 | Remove screws/bolts (6) from washer fluid reservoir (5) | When removing right front lamp unit (9). | |
| 6 | Press washer fluid reservoir (5) to one side until bolt (7) of right front lamp unit (9) is accessible. | When removing right front lamp unit (9). | |
| 7 | Remove bolt (7) | ||
| 8 | Remove screw/bolts (8) | ||
| 9 | Remove left front lamp unit or right front lamp unit (9) far enough until the electrical connectors on the left front lamp unit or right front lamp unit (9) are accessible | Carefully remove left front lamp unit or right front lamp unit (9). Left front lamp unit or right front lamp unit (9) may be damaged by the fender. |
|
| 10 | Disconnect electrical connectors from left front lamp unit or right front lamp unit (9) | ||
| 11 | Remove left front lamp unit or right front lamp unit (9) | ||
| 12 | Remove left front actuation module, LED exterior lighting or right front actuation module, LED exterior lighting | When replacing the left front lamp unit or right front lamp unit (9). | AR82.10-P-4650LF |
| 13 | Remove left headlamp control unit and right headlamp control unit | When replacing the left front lamp unit or right front lamp unit (9). | AR82.10-P-4660LF |
| 14 | Install in the reverse order | ||
| 15 | Carry out initial startup of left front lamp unit or right front lamp unit (9) | When replacing the left front lamp unit or right front lamp unit (9). | |
| AD00.00-P-2000-04B | |||
| Check | |||
| 16 | Check headlamp adjustment and correct if necessary | ||
| AP82.10-P-8260S |