Bleed Brake System - AR42.10-P-0010MFA

Model 118, 177, 243, 247 

Shown on model 177.087 

Courtesy of MERCEDES-BENZ USA

	Risk of death  caused by vehicle slipping or toppling off of the lifting platform.	Align vehicle between vehicle lift columns and position the four support plates at the vehicle lift support points specified by the vehicle manufacturer.	AS00.00-Z-0010-01A
	Risk of poisoning  from swallowing brake fluid. Risk of injury  from skin and eye contact with brake fluid	Only pour brake fluid into suitable and appropriately marked containers. Wear protective clothing and eye protection when handling brake fluid.	AS42.50-Z-0001-01A
Notice	Notes on repairs to brake system		AH42.00-P-0003-01A
Notice	Notes on handling, transport and storage of composite brake disks		AH42.10-P-9406-12LF
Notice	Brake fluid notes		AH42.50-P-0001-01A
	Notes on safety-relevant components		AH00.00-Z-0019-01A
	Remove
1	Clean area around cap (2) of brake fluid reservoir (1).	Assembly cleaner	*BR00.45-Z-1028-04A
2	Unscrew cap (2) of brake fluid reservoir (1).
	Bleeding
3	Fill brake fluid reservoir (1) with new brake fluid up to maximum mark.
	Brake fluids (DOT 4 plus)		BB00.40-P-0331-00A
	General brake fluid		BB00.40-P-0330-01A
4	Connect filling unit to brake fluid reservoir (1).
	000 588 16 82 00 Filling unit		WS25.00-P-0038B
	General brake fluid		BB00.40-P-0330-01A
	Brake fluids (DOT 4 plus)		BB00.40-P-0331-00A
		Observe manufacturer's operating instructions.
5	Switch on filling unit.
6	Lift vehicle with vehicle lift.		AR00.60-P-1006A
7	Bleed the system.
	000 588 16 82 00 Filling unit		WS25.00-P-0038B
			AR42.10-P-0010-02MFA
		Vent screw on brake caliper (floating brake caliper)	*BA42.10-P-1004-12X
		Bleed screw at brake caliper	*BA42.10-P-1004-10ZA
8	Switch off filling unit and disconnect from brake fluid reservoir (1).
	000 588 16 82 00 Filling unit		WS25.00-P-0038B
9	Check brake system for leaks.		AR42.10-P-0100-01MFA
10	Correct fluid level in brake fluid reservoir (1).
		Model 243	AP42.10-P-4210I
		Model 118, 177, 247	AP42.10-P-4210D
	Install
11	Seal brake fluid reservoir (1) with cap (2).
12	Lower vehicle with vehicle lift.		AR00.60-P-1006A