Replace Brake Fluid - AP42.00-P-4280D
Model 463
up to model year 2019
Shown: Model 463.348
| Risk of injury. Skin or eye injuries may result when handling hot or glowing objects. | Wear protective gloves, protective clothing and safety glasses, if necessary. | AS00.00-Z-0002-01A | |
| Risk of death caused by vehicle slipping or toppling off of the lifting platform. | Align vehicle between vehicle lift columns and position the four support plates at the vehicle lift support points specified by the vehicle manufacturer. | AS00.00-Z-0010-01A | |
| Risk of poisoning from swallowing brake fluid. Risk of injury from skin and eye contact with brake fluid | Only pour brake fluid into suitable and appropriately marked containers. Wear protective clothing and eye protection when handling brake fluid. | AS42.50-Z-0001-01A | |
| Risk of accident when commissioning the vehicle due to a lack of braking effect when the service brake is operated for the first time after repair work. | Before starting the engine, actuate brake pedal several times until pressure is built up and maintained in the brake system. | AS42.50-Z-0002-01A | |
| Notes on repairs to brake system | AH42.00-P-0003-01A | ||
| Brake fluid notes | AH42.50-P-0001-01A | ||
| Clean | |||
| 1 | Clean area surrounding cap (2) and expansion reservoir (1). | ||
| Remove | |||
| 2 | Unscrew cap (2). | ||
| 3 | Extract brake fluid from expansion reservoir (1). | ||
| 4 | Add new brake fluid up to the max. marking in the expansion reservoir (1). | ||
| 5 | Connect filling and bleeding unit to expansion reservoir (1) and switch on. | Note operating instructions for filling and bleeding unit. Damage can otherwise occur. |
|
| Change fluid | |||
| 6 | Lift vehicle with lifting platform. | ||
| AR00.60-P-1000G | |||
| 7 | Renew brake fluid. | ||
| General brake fluid | BB00.40-P-0330-01A | ||
| Brake fluids (DOT 4 plus) | BB00.40-P-0331-00A | ||
| Model 463.236/248 up to model year 2019 with code 979 (Special protection MB Guard) |
AR42.10-P-0010GS | ||
| Model 463.270/271 up to model year 2019 |
AR42.10-P-0010GX | ||
| Model 463 (except 463.270/271) up to model year 2013 except code 979 (Special protection MB Guard) |
AR42.10-P-0010-02GG | ||
| Model 463 as of model year 2013 up to model year 2016 |
AR42.10-P-0010-02GW | ||
| Model 463 as of model year 2016 up to model year 2019 |
AR42.10-P-0010-02GWA | ||
New brake fluid must escape without any bubbles via the bleed hose. Damage can otherwise occur. |
|||
| *BA42.10-P-1001-02B | |||
up to model year 2019 Bleed screw to front axle floating brake caliper |
BA42.10-P-1001-03G | ||
| *BA42.10-P-1001-17B | |||
↓ Detach/attach wheel and tire assemblies. |
*BA42.10-P-1005-16A | ||
| 8 | Replace clutch operation system brake fluid. | Vehicle with manual transmission. | |
| General brake fluid | BB00.40-P-0330-01A | ||
| Brake fluids (DOT 4 plus) | BB00.40-P-0331-00A | ||
| New brake fluid must escape without any bubbles via the bleed hose. Damage can otherwise occur. |
|||
up to model year 2019 Bleed screw at clutch slave cylinder |
BA25.20-P-1001-01H | ||
| Check | |||
| 9 | Check brake system for leaks. | ||
| 10 | Check clutch operation for leak tightness. | Vehicle with manual transmission. | |
| Install | |||
| 11 | Lower vehicle with vehicle lift. | ||
| AR00.60-P-1000G | |||
| 12 | Disconnect filling and bleeding unit. | ||
| Check | |||
| 13 | Check fluid level in expansion reservoir (1). | AP42.10-P-4210C | |
| Install | |||
| 14 | Screw on cap (2). |
CLUTCH OPERATING SYSTEM
| Number | Designation | Transmission 717 | |
|---|---|---|---|
| BA25.20-P-1001-01H | Bleed screw at clutch slave cylinder | Nm | 3 |
FRONT AXLE FIXED BRAKE CALIPER
| Number | Designation | Model 461 (except 461.339) Model 463 up to model year 2019 |
|
|---|---|---|---|
| BA42.10-P-1001-02B | Bleed screw at front axle fixed brake caliper | Nm | 14 |
FRONT AXLE FLOATING BRAKE CALIPER
| Number | Designation | Model 463.270/271 | |
|---|---|---|---|
| BA42.10-P-1001-03G | Bleed screw to front axle floating brake caliper | Nm | 17 |
REAR AXLE FLOATING CALIPER
| Number | Designation | Model 461 Model 463 (except 463.270/271/272/273) up to model year 2019 |
Model 463.270/271/272/273 up to model year 2019 |
|
|---|---|---|---|---|
| BA42.10-P-1001-17B | Bleed screw on rear axle floating caliper | Nm | 15 | 17 |
REAR AXLE FLOATING CALIPER
| Number | Designation | Model 463 as of model year 2019 | |
|---|---|---|---|
| BA42.10-P-1001-17B | Bleed screw on rear axle floating caliper | Nm | 11 |
DRUM BRAKE
| Number | Designation | Model 463 | ||
|---|---|---|---|---|
| BA42.10-P-1005-16A | Vent screw at wheel cylinder | Manufacturer ATE | Nm | 3 |
| Manufacturer FAG | Nm | 6 | ||