LEMON Manuals: Even more car manuals for everyone
Home >> Mercedes Benz >> 2021 >> G550 >> Repair and Diagnosis >> Restraints >> Seat Belts >> Seats, Bunks, Restraint Systems - 463 Chassis (2 Of 3) >> Testing & Repair >> Remove/Install Airbag Unit On Steering Wheel >> (Remove/Install Airbag Unit On Steering Wheel - AR91.60-P-0660A)

(Remove/Install Airbag Unit On Steering Wheel - AR91.60-P-0660A)

Model 461 

as of model year 1998 

Model 463 

as of model year 1994 up to model year 2001 

MODIFICATION NOTES

11.10.2018 Disconnect electrical connector (5), added. Operation step 4  
12.10.2018 Dispose of removed airbag unit (4) properly, added. Operation step 7  

Shown on steering wheel in model 461.333 with code ZD4 (Vehicle for non-civilian use) 

G13670581Courtesy of MERCEDES-BENZ USA
WARNING Risk of injury  caused by performing testing or repair work on airbag or emergency tensioning retractor units. Store airbag units with deployment side facing up; do not expose to temperatures greater than 100 °C. When working on these units, disconnect the power supply. Model 461 as of 4/1/94
as of model year 1998
Model 463
as of model year 1994 up to model year 2001
AS91.00-Z-0001-01A
  Information on preventing damage to electronic components due to electrostatic discharge   AH54.00-P-0001-01A
  Information, assessment and legal requirements when working with, handling and storing pyrotechnical components   AH91.00-Z-0000-10A
REMOVINGINSTALLING Remove/install     
1 Switch off ignition and store transmitter key outside of the transmission range (for at least 2 minutes).    
2 Disconnect ground line from battery. Model 461
as of model year 1998
Model 463
as of model year 1994 up to model year 2001
Model 461.326/327/335/366 as of model year 1998
Model 463.206/208/209/231/232/233/240/244/245/246/247/249/250/254/308/309/322/323/330/331/332/333
as of model year 1994 up to model year 2001
AR54.10-P-0003G
    Model 461.302/331/332/333/340/342/343/344/345/392
as of model year 1998
AR54.10-P-0003GL
3 Remove bolts (1) on rear of steering wheel (2) and lift off airbag unit (4). TORQUE SPECIFICATION Screw/bolt, airbag to steering wheel *BA91.60-P-1001-01B 
    SPECIAL TOOL Screwdriver bit Fig 1
4 Release and disconnect electrical connector (5).    
5 Release and disconnect electrical connection (3). INSTALLATION IMPORTANT Make sure that the electrical connector (3) engages properly.
SPECIAL TOOL Removal lever
Fig 2
6 Remove airbag unit (4) from steering wheel (2).    
7 Dispose of removed airbag unit (4) properly. Only when replacing airbag unit (4).  
8 Install in the reverse order.    
INSPECT Check     
9 Check Supplemental Restraint System (SRS) with diagnostic device. Only when replacing airbag unit (4).  
REFER TO SELF-DIAGNOSTIC SYSTEMS     AD00.00-P-2000-04A
AIRBAG

Number Designation Model 461 Model 463 up to 11/30/00 up to model year 2019
BA91.60-P-1001-01B Screw/bolt, airbag to steering wheel Nm 6 6
AIRBAG

Number Designation Model 463 as of 12/1/00 up to model year 2019
BA91.60-P-1001-01B Screw/bolt, airbag to steering wheel Nm 8
Fig 1: Identifying Screwdriver Bit (126 589 00 10 00)
G13670582Courtesy of MERCEDES-BENZ USA
Fig 2: Identifying Removal Lever (203 589 04 33 00)
G13670583Courtesy of MERCEDES-BENZ USA