LEMON Manuals: Even more car manuals for everyone
Home >> Mercedes Benz >> 2021 >> E350 Base >> Repair and Diagnosis >> Collision >> Body Panels >> Collision - Side Wall (213 Chassis) >> Testing & Repair >> Cut Off B-Pillar - Ar63.20-P-1350-05LWE

Cut Off B-Pillar - Ar63.20-P-1350-05LWE

Model 213 

IMPORTANT The following steps are shown on the left side of the vehicle and must be performed analogously on the right side in the event of damage.

G13773996Courtesy of MERCEDES-BENZ USA
  1. Mark separations on B-pillar paneling (1) and cut (areas A, B and C).

    NOTES Do not make the cuts too deep.

    Otherwise the components below can be damaged and weakened.

  2. Expose spot welds on A-pillar paneling (1) and cut out (areas D).

    IMPORTANT Joint spot welds in B-pillar paneling (1) and B-pillar reinforcement must be cut out through two panel thicknesses.

    IMPORTANTDimensions: 

    a = approx. 30 mm

    b = approx. 35 mm

    c1 = approx. 15 mm

    c2 = approx. 20 mm

    c3 = approx. 40 mm

    G13773997Courtesy of MERCEDES-BENZ USA
  3. Heat B-pillar paneling (1) in crosshatched areas.

    IMPORTANT Cross-hatched areas are bonded with adhesive.

  4. Remove B-pillar paneling (1).
    G13773998Courtesy of MERCEDES-BENZ USA
  5. Mark separating points on B-pillar reinforcement (2) and cut (areas E and F).

    NOTES Do not make the cuts too deep.

    Otherwise the components below can be damaged and weakened.

    IMPORTANT Mark separating points on Y-marking on longitudinal member outer shell.

  6. Expose inert gas welds on inner B-pillar reinforcement (2) and cut (areas G).
    G13773999Courtesy of MERCEDES-BENZ USA
    G13774000Courtesy of MERCEDES-BENZ USA
  7. Expose spot welds on B-pillar reinforcement (2) and cut out (areas H and J).

    IMPORTANT Cut out spot welds through two panel thicknesses (area J).

    G13774001Courtesy of MERCEDES-BENZ USA
  8. Heat B-pillar reinforcement (2) in crosshatched areas.

    IMPORTANT Cross-hatched areas are bonded with adhesive.

  9. Remove B-pillar reinforcement (2).
  10. Sand down mating surfaces to bare metal in cross-hatched areas.

    IMPORTANT Sand down spot weld flanges to bare metal on both sides.

  11. Remove grinding dust and drill chips.
  12. Coat insides of spot weld flanges with zinc dust paint.

    NOTES Do not coat bonding surfaces with zinc dust paint (areas K).

    Otherwise adhesion problems may occur.

    IMPORTANT Observe pretreatment of bonding surfaces.

    G13774002Courtesy of MERCEDES-BENZ USA