Remove/Install Headliner - AR68.30-P-4300CLW
Model 205.3
Shown with code 413 (Panoramic sliding roof)
Shown with code 235 (Active park assist with PARKTRONIC)
| Remove/install | |||
| 1 | Remove windshield | AR67.10-P-1000LW | |
| 2 | Completely open roller sun blind on panoramic roof | Model 205.3 with code 413 (Automatic panoramic sliding sunroof) |
|
| 3 | Remove inside rearview mirror (A67) | AR68.40-P-0001LW | |
| 4 | Fold back foam material (12) and disconnect electrical connector (13) | Model 205.3 with code 235 (Active Parking Assist with PARKTRONIC) Completely pull foam material (12) over electrical connector (13). Otherwise noises can occur. |
|
| 5 | Remove left and right sun visor (2). | AR68.60-P-5480NKB | |
| 6 | Unclip the left and right cover (3) from the headliner (1). | ||
| 7 | Remove left and right A-pillar paneling (4) | AR68.30-P-4050LW | |
| 8 | Remove left and right B-pillar paneling (5) | AR68.30-P-4700CLW | |
| 9 | Remove the left and right coat hook (8) and unscrew the bolts below. | Fig 1 | |
| 10 | Remove left and right C-pillar paneling (6) and lay down to side with installed seat belts | AR68.30-P-4490CLW | |
| 11 | Remove the edge guards (7) from the body flange in the area of the headliner (1). | ||
| 12 | Press the catch hooks (arrows) together and unclip the headliner (1) from the front roof frame | ||
| 13 | Push headliner (1) toward rear until guide hooks are unhooked from rear roof frame and lay headliner (1) down on vehicle | ||
| 14 | Remove headliner (1) toward front | Otherwise the headliner (1) can be damaged. |
|
| 15 | Make sure that all of the soundproofing on the headliner (1) is properly attached and in good condition. | Model 205.3 with code 494 (US version) If the headliner (1) is reused. If complaint present ↓ Replace the affected soundproofing on the headliner (1). |
|
| 16 | Prepare new headliner (1) for installation | When replacing roof paneling (1). | AR68.30-P-4305-16LW |
| Adhesive tape roll, non-woven Tesa tape, 50 meters, 50 mm wide | *BR00.45-Z-1144-02A | ||
| 17 | Install in the reverse order |
REPAIR MATERIALS
| Number | Designation | Order number |
|---|---|---|
| BR00.45-Z-1144-02A | Adhesive tape roll, non-woven Tesa tape, 50 meters, 50 mm wide | A 008 989 50 85 09 |