Remove/Install Panoramic Sunroof Drive Guide Rail - AR77.21-P-0430NKA
WARNING: This page is about a different car, the 2023 Mercedes-Benz C300, 2022 Mercedes-Benz C300, 2021 Mercedes-Benz C300, 2020 Mercedes-Benz C300, and 2019 Mercedes-Benz C300. However, it is still accessible from the selected car via links, so may be relevant.
Model 117, 156, 176
with code 413 (Panoramic Sliding Sunroof/Glass Roof)
Model 205.0/1/2/3
with code 413 (Panoramic Sliding Sunroof/Glass Roof)
Model 222
with code 398 (Panoramic Roof With MAGIC SKY CONTROL)
Model 222
with code 413 (Panoramic Sliding Sunroof/Glass Roof)
Model 238
with code 413 (Panoramic Sliding Sunroof/Glass Roof)
Model 253
with code 413 (Panoramic Sliding Sunroof/Glass Roof)
MODIFICATION NOTES
| 15.08.2017 | "Manually adjust mechanical Sliding Sunroof components fully toward rear until limit stop via motor emergency actuation" added. | Operation step 24.2 |
Shown on Model 176, on right panoramic Sliding Sunroof guide rail (1)
| Risk of death when working on component parts and systems with U >= 30 V alternating voltage (AC) or U >= 60 V direct voltage (DC) | Do not touch damaged or defective live component parts and lines or non-insulated electrical connections and lines. Model 222 with code 398 (Panoramic Roof With MAGIC SKY CONTROL) |
AS00.00-Z-0035-01A | |
| Risk Of Injury caused by fingers being jammed or pinched when removing, installing or aligning hoods, doors, trunk lid/rear-end door or sliding roof. | No parts of the body or limbs should be within the operating area when the components are moving. | AS00.00-Z-0011-01A | |
|
Topical Note |
Notes on MAGIC SKY CONTROL | Model 222 with code 398 (Panoramic Roof With MAGIC SKY CONTROL) | AH77.00-P-0001-01A |
|
Topical Note |
Information on preventing damage to electronic components due to electrostatic discharge | AH54.00-P-0001-01A | |
| Remove | |||
| 1 | Completely open panorama sliding roof | ||
| 2 | Completely open rear roller sun blind | Model 156, 205.0/1/2, 222, 253 with code 413 (Panoramic Sliding Sunroof/Glass Roof) Model 222 with code 398 (Panoramic Roof With MAGIC SKY CONTROL) |
|
| 3 | Remove cover (8) | ||
| 4 | Remove wind deflector | Model 117, 156, 176 with code 413 (Panoramic Sliding Sunroof/Glass Roof) | AR77.21-P-0100NKA |
| Model 205.0/1/2/3, 222, 238, 253 with code 413 (Panoramic Sliding Sunroof/Glass Roof) Model 222 with code 398 (Panoramic Roof With MAGIC SKY CONTROL) |
AR77.21-P-0100LF | ||
| 5.1 | Remove roof lining until screws (2, 3) on left or right panoramic Sliding Sunroof guide rail (1) can be accessed | Model 117, 156, 176, 205.0/1/3, 222 with code 413 (Panoramic Sliding Sunroof/Glass Roof) Model 222 with code 398 (Panoramic Roof With MAGIC SKY CONTROL) Model 156 with code 413 (Panoramic Sliding Sunroof/Glass Roof) |
AR68.30-P-4300NKX |
| Model 117, 176 with code 413 (Panoramic Sliding Sunroof/Glass Roof) | AR68.30-P-4300NKA | ||
| Model 205.0/1 with code 413 (Panoramic Sliding Sunroof/Glass Roof) | AR68.30-P-4300LW | ||
| Model 205.3 with code 413 (Panoramic Sliding Sunroof/Glass Roof) | AR68.30-P-4300CLW | ||
| Model 222.0 with code 398 (Panoramic Roof With MAGIC SKY CONTROL) Model 222.0 with code 413 (Panoramic Sliding Sunroof/Glass Roof) |
AR68.30-P-4300LF | ||
| Model 222.1 with code 398 (Panoramic Roof With MAGIC SKY CONTROL) with code 413 (Panoramic Sliding Sunroof/Glass Roof) Model 222.9 with code 398 (Panoramic Roof With MAGIC SKY CONTROL) except code Z07 (B7 armoring on special protection version) with code 413 (Panoramic Sliding Sunroof/Glass Roof) except code Z07 (B7 armoring on special protection version) |
AR68.30-P-4300LFN | ||
| 5.2 | Remove headliner | Model 205.2, 238, 253 with code 413 (Panoramic Sliding Sunroof/Glass Roof) Model 205.2, 253 with code 413 (Panoramic Sliding Sunroof/Glass Roof) |
AR68.30-P-4300LWS |
| Model 238.3 with code 413 (Panoramic Sliding Sunroof/Glass Roof) | AR68.30-P-4300LWO | ||
| 6 | Remove panoramic sliding roof control module | Model 117, 156, 176, 205.0/1/2/3, 222, 253 with code 413 (Panoramic Sliding Sunroof/Glass Roof) Model 222 with code 398 (Panoramic Roof With MAGIC SKY CONTROL) |
AR77.21-P-6995NKA |
| Model 238 with code 413 (Panoramic Sliding Sunroof/Glass Roof) | AR77.21-P-0002LWO | ||
| 7 | Remove roller sun blind motor on panoramic sliding roof | Model 117, 156, 176, 205.0/1/2/3, 222, 253 with code 413 (Panoramic Sliding Sunroof/Glass Roof) Model 222 with code 398 (Panoramic Roof With MAGIC SKY CONTROL) |
AR77.21-P-0490NKA |
| Model 238.3 with code 413 (Panoramic Sliding Sunroof/Glass Roof) | AR77.21-P-0490LWO | ||
| 8 | Remove front roller sun blind | Model 117, 176 with code 413 (Panoramic Sliding Sunroof/Glass Roof) | AR77.21-P-0215NKA |
| Model 156, 205.0/1/2/3, 238, 253 with code 413 (Panoramic Sliding Sunroof/Glass Roof) | AR77.21-P-0200NKX | ||
| Model 222 with code 398 (Panoramic Roof With MAGIC SKY CONTROL) Model 222 with code 413 (Panoramic Sliding Sunroof/Glass Roof) |
AR77.21-P-0200LF | ||
| 9 | Remove left or right panoramic roof roller sunblind drive cable | AR77.21-P-0230NKA | |
| 10 | Unscrew screw (4) on left or right panoramic Sliding Sunroof guide rail (1) | ||
| 11 | Remove left and right guide tube(6) from roller sun blind drive cable | Model 117, 156, 176, 205.0/1/2/3, 222, 238, 253 with code 413 (Panoramic Sliding Sunroof/Glass Roof) Model 222 with code 398 (Panoramic Roof With MAGIC SKY CONTROL) Model 156, 205.0/1/2, 253 with code 413 (Panoramic Sliding Sunroof/Glass Roof) |
AR77.21-P-0232NKX |
| 12 | Unscrew screws (2, 3) on left or right panoramic Sliding Sunroof guide rail (1) | Observe installation position on bolts (3). Number of screws (3) depends on change status of panoramic Sliding Sunroof guide rail (1). |
|
| 13 | Remove left and right panoramic sliding roof guide rail(1) from panoramic sliding roof and pull panoramic sliding roof drive cable(5) from guide tube(6) | ||
| Install | |||
| 14 | Manually turn back compensation elements (7) | Expansion elements (7) should be easy to move. Panoramic Sliding Sunroof guide rail (1) is otherwise damaged during fastening into place. If compensating elements (7) are sluggish. ↓ Replace compensating elements (7). |
|
| 15 | Insert panoramic Sliding Sunroof drive cable (5) into guide tube (6) and insert panoramic Sliding Sunroof guide rail (1) into panoramic Sliding Sunroof frame | Carefully insert panoramic Sliding Sunroof guide rail (1). Otherwise the guide tube (6) can be damaged. |
|
| 16 | Fit bolts(3) | Observe installation position on bolts (3). Screws (3) are initially tightened after installation of panoramic Sliding Sunroof. Number of screws (3) depends on change status of panoramic Sliding Sunroof guide rail (1). |
|
| 17 | Screw in screws (2) on panoramic Sliding Sunroof guide rail (1) | ||
| 18 | Screw in screw (4) on panoramic Sliding Sunroof guide rail (1) | ||
| 19 | Install guide tube(6) on roller sun blind drive cable | Model 117, 156, 176, 205.0/1/2/3, 222, 238, 253 with code 413 (Panoramic Sliding Sunroof/Glass Roof) Model 222 with code 398 (Panoramic Roof With MAGIC SKY CONTROL) Model 156, 205.0/1/2, 253 with code 413 (Panoramic Sliding Sunroof/Glass Roof) |
AR77.21-P-0232NKX |
| 20 | Manually slide mechanical Sliding Sunroof components on left and right panoramic Sliding Sunroof guide rail (1) fully toward front up to end stop | ||
| 21 | Install panoramic sliding roof control module | Model 117, 156, 176, 205.0/1/2/3, 222, 253 with code 413 (Panoramic Sliding Sunroof/Glass Roof) Model 222 with code 398 (Panoramic Roof With MAGIC SKY CONTROL) |
AR77.21-P-6995NKA |
| Model 238 with code 413 (Panoramic Sliding Sunroof/Glass Roof) | AR77.21-P-0002LWO | ||
| 22 | Connect overhead control panel control unit to on-vehicle wiring harness | ||
| 23 | Connect ground cable to battery | Model 222 with code 398 (Panoramic Roof With MAGIC SKY CONTROL) | AR54.10-P-0003LF |
| 24.1 | Completely adjust mechanical sliding roof components with panoramic sliding roof switch toward rear to end stop | Where panoramic Sliding Sunroof control module is reused | |
| 24.2 | Manually adjust mechanical Sliding Sunroof components fully toward rear until limit stop via motor emergency actuation. | When replacing panoramic Sliding Sunroof control module | |
| 25 | Install panoramic sliding roof drive cable | AR77.21-P-0230NKA | |
| 26 | Install roller sun blind at front | Model 117, 176 with code 413 (Panoramic Sliding Sunroof/Glass Roof) | AR77.21-P-0215NKA |
| Model 156, 205.0/1/2/3, 238, 253 with code 413 (Panoramic Sliding Sunroof/Glass Roof) | AR77.21-P-0200NKX | ||
| Model 222 with code 398 (Panoramic Roof With MAGIC SKY CONTROL) Model 222 with code 413 (Panoramic Sliding Sunroof/Glass Roof) |
AR77.21-P-0200LF | ||
| 27 | Install motor for roller sun blind on panoramic sliding roof | Model 117, 156, 176, 205.0/1/2/3, 222, 253 with code 413 (Panoramic Sliding Sunroof/Glass Roof) Model 222 with code 398 (Panoramic Roof With MAGIC SKY CONTROL) |
AR77.21-P-0490NKA |
| Model 238.3 with code 413 (Panoramic Sliding Sunroof/Glass Roof) | AR77.21-P-0490LWO | ||
| 28 | Install wind deflector | Model 117, 156, 176 with code 413 (Panoramic Sliding Sunroof/Glass Roof) | AR77.21-P-0100NKA |
| Model 205.0/1/2/3, 222, 238, 253 with code 413 (Panoramic Sliding Sunroof/Glass Roof) Model 222 with code 398 (Panoramic Roof With MAGIC SKY CONTROL) |
AR77.21-P-0100LF | ||
| 29 | Install covering (8) | ||
| 30 | Install movable glass section | Model 117, 156, 176, 205.0/1/2/3, 222, 253 with code 413 (Panoramic Sliding Sunroof/Glass Roof) Model 222 with code 398 (Panoramic Roof With MAGIC SKY CONTROL) |
AR77.21-P-0500NKA |
| Model 238 with code 413 (Panoramic Sliding Sunroof/Glass Roof) Do not adjust panoramic sliding roof. |
AR77.21-P-0503LWO | ||
| 31 | Fully close movable glass section | ||
| 32.1 | Push movable glass section at transition to rear roof trim downward and tighten screws (3) | Model 117, 156, 176 with code 413 (Panoramic Sliding Sunroof/Glass Roof) Rear edge of movable glass section must be approx. 1 mm lower than roof trim. After tightening, the rear edge of the closed movable glass section must be flush or max. 2 mm higher than rear roof trim. |
|
| 32.2 | Push movable glass section at transition to rear fixed glass section downward and tighten screws (3) | Model 205.0/1/2/3, 222, 238, 253 with code 413 (Panoramic Sliding Sunroof/Glass Roof) Model 222 with code 398 (Panoramic Roof With MAGIC SKY CONTROL) The rear edge of the movable glass section must be approx. 1 mm lower than the fixed glass section. After tightening, the rear edge of the closed movable glass section must be flush or max. 2 mm higher than the rear fixed glass section. |
|
| 33 | Adjust panoramic sliding roof | Model 117, 156, 176, 205.0/1/2/3, 222, 253 with code 413 (Panoramic Sliding Sunroof/Glass Roof) Model 222 with code 398 (Panoramic Roof With MAGIC SKY CONTROL) |
AR77.21-P-0501NKA |
| Model 238 with code 413 (Panoramic Sliding Sunroof/Glass Roof) | AR77.21-P-6924LWO | ||
| 34 | Disconnect battery ground line | Model 222 with code 398 (Panoramic Roof With MAGIC SKY CONTROL) | AR54.10-P-0003LF |
| 35 | Disconnect overhead control panel control unit from vehicle wiring harness | ||
| 36 | Install headliner | Model 156 with code 413 (Panoramic Sliding Sunroof/Glass Roof) | AR68.30-P-4300NKX |
| Model 117, 176with code 413 (Panoramic Sliding Sunroof/Glass Roof) | AR68.30-P-4300NKA | ||
| Model 205.0/1 with code 413 (Panoramic Sliding Sunroof/Glass Roof) | AR68.30-P-4300LW | ||
| Model 205.3 with code 413 (Panoramic Sliding Sunroof/Glass Roof) | AR68.30-P-4300CLW | ||
| Model 205.2, 253 with code 413 (Panoramic Sliding Sunroof/Glass Roof) | AR68.30-P-4300LWS | ||
| Model 222.0 with code 398 (Panoramic Roof With MAGIC SKY CONTROL) Model 222.0 with code 413 (Panoramic Sliding Sunroof/Glass Roof) |
AR68.30-P-4300LF | ||
| Model 222.1 with code 398 (Panoramic Roof With MAGIC SKY CONTROL) with code 413 (Panoramic Sliding Sunroof/Glass Roof) Model 222.9 with code 398 (Panoramic Roof With MAGIC SKY CONTROL) except code Z07 (B7 armoring on special protection version) with code 413 (Panoramic Sliding Sunroof/Glass Roof) except code Z07 (B7 armoring on special protection version) |
AR68.30-P-4300LFN | ||
| Model 238.3 with code 413 (Panoramic Sliding Sunroof/Glass Roof) | AR68.30-P-4300LWO | ||
| 37 | Normalize panoramic Sliding Sunroof with vehicle diagnosis system and perform teach-in run for automatic reversing function | ||
| Model 117, 156, 176 with code 413 (Panoramic Sliding Sunroof/Glass Roof) | AD00.00-P-2000-04A | ||
| Model 205.0/1/2/3, 222, 253with code 413 (Panoramic Sliding Sunroof/Glass Roof) Model 222 with code 398 (Panoramic Roof With MAGIC SKY CONTROL) |
AD00.00-P-2000-04B | ||
| Model 238 with code 413 (Panoramic Sliding Sunroof/Glass Roof) | AD00.00-P-2000-06LWO |